钢铁行业常用英语词汇

热轧生产常用专用英语词汇2008-12-29 09:53Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapour cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却Head water tunk 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Saddle 鞍座Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度MPM: meter per minute 米/分钟Torque 扭矩Rated torque 额定扭矩Voltage 电压Process computer 过程计算机Program 程序，编程PLC： programmable logic controller 可编程控制器Encoder 编码器Information 信息Ghost rolling 模拟轧制Measuring instrument 测量仪表X-ray X射线Thickness gauge 测厚仪Width gauge 测宽仪HMD: hot material detector 热金属探测仪CMD: cold material detector 冷金属探测仪Light barrier 光栅Automatic model 自动模式Semi-auto model 半自动模式Manual model 手动模式Emergency 紧急，急停Joggle 点动HMI：human machine interface 人机界面AC frequency converter 交流变频器I/O： input/output 输入/输出端口Step control 卷取机助卷辊的“踏步”控制Hydraulic system 液压系统Grease 甘油Oil 油，稀油Oil station 油站SSC: Short stroke control 短行程控制AGC: automatic gauge control 自动压下控制AWC: automatic width control 自动宽度控制Pump 泵Screw pump 螺杆泵Filter 过滤器，滤网Cylinder 液压缸，圆柱体Valve stand 阀台Accumulator 蓄能器Leakage 泄漏Product 产品Grade 钢种Batch 一炉，一批Batch No. 炉批号Coil 钢卷Strip 带钢，薄带钢Sheet 钢板，薄钢板Plate 中厚板Physical performance 物理性能Mechanical performance 机械性能Strength 强度Elongation 延伸Flatness 平直度Plasticity 塑性Crown/chamber 凸度Hardness 硬度Microstructure 微观组织结构Austenite 奥氏体Ferrite 铁素体Pearlite 珠光体Deep drawn 深冲SPHC 普通级热轧钢板（卷）SPHD 深冲级热轧钢板（卷）SPCC 普通级冷轧钢板（卷）SPCD 深冲级冷轧钢板（卷High strength low-alloy steel 低合金高强度钢Silicon steel 硅钢，电工钢Galvanizing 镀锌Coating 涂镀，涂层Heat treatment 热处理Aging 时效处理Annealing 退火Quenching 淬火OtherAlarm 报警Anchoring bolt 地脚螺栓Yield 产量，成材率Ton 吨Annual 一年的Month 月Day 日Shift 班Safety 安全Radioactive hazard 放射性伤害Caution 注意，小心Layout 平面布置Document 文件Documentation 技术文本，技术文件报价书TOP: take-over point 交接点4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes 统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes 化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation 反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram 二元相图binary-component phase diagram 三元相图ternary-component phase diagram 液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution 相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion 菲克第一扩散定律Fick’s 2nd law of diffusion 扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance 蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,VAR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制 long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping铸铁cast iron熟铁wrought iron电解铁electrolytic iron白口铸铁white cast iron灰口铸铁grey cast iron麻口铸铁mottled cast iron变性铸铁modified cast iron孕育铸铁inoculated cast iron冷硬铸铁chilled cast iron球墨铸铁nodular cast iron蠕墨铸铁vermicular cast iron可锻铸铁malleable cast iron半可锻铸铁semi-malleable cast iron奥氏体铸铁austenitic cast iron贝氏体铸铁bainitic cast iron共晶白口铁eutectic white iron亚共晶白口铁hypoeutectic white iron过共晶白口铁hypereutectic white iron结构钢constructional steel软钢mild steel普通碳素钢plain carbon steel正火钢normalized steel热轧钢hot rolled steel高强度低合金钢high-strength low-alloy steel 微合金钢micro-alloy steel冷轧钢cold rolled steel深冲钢deep drawing steel双相钢dual phase steel渗碳钢carburizing steel渗氮钢nitriding steel调质钢quenched and tempered steel超高强度钢ultra-high strength steel不锈钢stainless steel奥氏体不锈钢austenitic stainless steel铁素体不锈钢ferritic stainless steel马氏体不锈钢martensitic stainless steel双相不锈钢duplex stainless steel马氏体时效钢maraging steel耐蚀钢corrosion-resisting steel耐热钢heat-resisting steel弹簧钢spring steel易切削钢free-machining steel耐磨钢abrasion-resistant steel工具钢tool steel高速钢high-speed steel冷作模具钢cold-work die steel热作模具钢hot-work die steel钢筋钢reinforced bar steel钢轨钢rail steel轮箍钢type steel管线钢pipe line steel锅炉钢boiler steel电工钢electrical steel∧-shaped segregation倒V形偏析∨-shaped segregation V形偏析1 mass% solution standard质量１％溶液标准(态) abrasion resistance耐磨损性abrasion-resistant steel耐磨钢absorption吸附absorption吸收accelerated melting by coal-oxygen burner氧煤助熔acid open-hearth furnace酸性平炉acid oxide酸性氧化物acid refractory [material] 酸性耐火材料acid slag酸性渣activation energy活化能activity coefficient活度系数activity活度addition reagent添加剂adiabatic process绝热过程adjustable mold调宽结晶器after blow后吹agglomeration团聚aim carbon目标碳air bottom-blown acid converter酸性空气底吹转炉air bottom-blown basic converter碱性空气底吹转炉air gap空气隙air mist spray cooling气水喷雾冷却akermanite镁黄长石Al2O3-SiC-C brick氧化铝-碳化硅-炭砖alumina carbon brick 铝炭砖alumina chrome brick铝铬砖alumina magnesia brick铝镁炭转alumina氧化铝aluminium bullet shooting, ABS 铝弹脱氧法aluminosillicate refractory硅酸铝质耐火材料aluminothermic process, thermit process铝热法amorphous carbon无定形碳amphoteric两性氧化物andalusite红柱石andradite钙铁榴石anion阴离子annual mine output矿山年产量anode阳极anorthite钙长石apparent activation energy表现活化能arc bias 偏弧argon-oxygen decarburization process, AOD氩氧脱碳法Arrhenius equation阿伦尼乌斯方程arrival at mine full capacity矿山达产Arved lance carbon injection process, ALCI顶枪喷煤粉炼钢法asbestos石棉ASEA-SKF process电弧加热电磁搅拌钢包精炼法austenitic cast iron奥氏体铸铁austenitic stainless steel奥氏体不锈钢back pour, back feeding补浇bainitic cast iron贝氏体铸铁baling of scrap废钢打包ball growth by assimilation生球长大同化机理ball growth by coalescence生球长大聚合机理ball growth by layering生球长大成层机理ball mill球磨机balling disc圆盘造球机balling drum圆筒造球机balling index for iron ore concentrates精矿成球指数banking for coke oven焦炉焖炉barite重晶石basic open-hearth furnace碱性平炉basic refractory [material] 碱性耐火材料basic slag碱性渣basicity of slag渣碱度basicoxide碱性氧化物bauxite铝土矿bell-less charging 无料钟装料belly炉腰bending roll弯曲辊bentonite 膨润土benzene苯billet caster小方坯连铸机binary-component phase diagram二元相图blast conditioning下部[鼓风]调节blast furnace campaign高炉寿命blast furnace process高炉炼铁[法]blast furnace高炉blast furnace鼓风炉blast humidity鼓风湿度blast pressure风压blast temperature风温blast volume鼓风量blast鼓风bleeder放散管bleeding valve炉顶放散阀bleeding 渗漏block flow sheet方框流程bloom caster大方坯连铸机blow end point吹炼终点blow off valve放散阀blow off停炉blow on开炉blowhole气孔Bohler electroslag tapping, BEST电渣浇注boiler steel锅炉钢borax硼砂boron nitride氮化硼bosh angle炉腹角bosh炉腹bottom boil炉底沸腾bottom casting下铸bottom-blown converter底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace, QBOF氧气底吹转炉bottom炉底boundary layer边界层bow-type continuous caster弧形连铸机breaking out拉漏briquette压块矿bubbling鼓泡bulging鼓肚bulk concentrate混合精矿bulk concentration体内浓度burden conditioning上部[炉料]调节burner blower助燃风机burner shut-off valve切断阀burner燃烧器bustle pipe热风围管by-pass valve旁通阀calcite方解石calcium diferrite铁酸半钙calcium ferrite铁酸钙calcium silicon硅钙calorific value发热值calorimeter量热计capped steel压盖沸腾钢car casting车铸carbide slag电石渣carbon black 炭黑carbon block炭块carbon boil碳沸腾carbon brick炭砖carbon brush炭刷carbon electrode 炭电极carbon materials[含]碳[元]素材料carbon micrography炭相[学]carbon-oxygen equilibrium碳一氧平衡carburizing steel渗碳钢cast iron铸铁casting cycle浇注周期casting house出铁场耐磨性 abrasive气孔 abscess横坐标 abscissa容纳、收纳 accommodating空气喷射 air ejection气动电机 air motor自动踏步控制 AJC=automatic jumping control 定中心、对中 align排成直线、列队、对中 alignment交替、轮流 alternate电流量 amperage锚固、地脚 anchor退火的 annealed一年一次的 annual能应用的、适用的、适合的 applicable应用 application增多，重视 appreciate接近、进给 approach适合的、特有的 appropriate裙板 apron相变 arrest装配、组装、配件 assembly分配 assignment奥氏体 austenite奥氏体轧制 austenite rolling奥氏体的 austenitic辅助液压 auxiliary hydraulic轴向的 axial后退、退回 backlash平衡力 balance force球面丝杆 ball jack screw包装带分配器 banding dispenser 打捆带 banding strap冷却段 bank轴承架 bearing bracker轴承箱 bearing cage轴承座 bearing chock轴承滑块，托瓦 bearing shoes 口径、钻孔 bore支架、托架 bracket脆性 brittle青铜 bronze水桶，废品箱 bucket四轮小车 buggy衬板 bushing碰撞仪 butt gauge计算 calculation凸轮 cam曲线度 cambering amount辊型误差 cambering profile悬梁 cantilever有能力的 capable能力 capacity渗碳 carburized小车，砂轮架 carriage延伸辊道 carry over table连铸坯分段剪 CC shear中心线 centerline离心机 centrifuge房间 chamber轴承座 chock垫板 choke linerC形沟 C-hook溜槽 chute圆周运动 circular motion过滤设备 clean-up device间隙 clearance废钢收集装置 cobble catcher带卷打捆机 coil banding machine带卷运输机 coil conveyor带卷检查线 coil inspection line带卷提升机 coil lifter托卷臂 coil loading arm带卷打号机 coil marking machine开卷机 coil opener带卷鞍座 coil saddle带卷鞍座 coil skid带卷站 coil station卸卷小车 coil stripper car带卷回转台 coil turner带卷称重装置 coil weighter带卷跨 coil yard卷取机进口侧导板 coiler entry side guide 卷取温度 coiling temperature收缩状态 collapsed校准仪，准直仪 collimator燃烧 combustion补偿 compensated复杂的 complicate压缩空气 compressed air计算机数据传输线 computer data line凹面 concave构想，认为 conceive概念 concept水泥，钢筋混凝土 concrete条件 condition联接 conjunction控制台 console统一，一致 consortium控制器 controller凸面 convex凸形 convex profile输送，运输 convey冷却水 cooling water冷却水管 cooling water header相互作用 correlation腐蚀性的 corrosive支架 cradle托辊 cradle roll标准，准则 criterion临界点 critical point十字接头式万向接头 cross pin type universal joint结晶 crystallization立方体的 cubic曲线 curve剪切力 cutting force剪切速度 cutting speed周期的 cyclic圆柱度 cylindricity缓冲，减振 dampen十年 decade缺陷 defect偏转辊 deflector roll变形 deformation变形抗力 deformation resistance不管，危害 despite超声波式涡流探伤仪 detector of ultrasonic or eddy current type消耗，磨损 deteriorate不利的，有害的 detrimental数字位置传感器 digital positioning sensor先导伺服阀 diredt servo valve散乱，分散 dispersion忽视 disregard明显的，不同的 distinct分配器 distributor龙门式 double column type地下卷取机 down coiler翻转装置 down ender下游的 downstream转鼓 drum转鼓更换钩 drum changing hook柔性，柔软的 ductile延展性，延伸率 ductility变钝，钝的 dull动态的 dynamic动平衡 dynamic balance偏心套 eccentricity ring偏心轴 eccentricity shaft弹性材料 elastic material电液伺服控制 electro-hydraulic servo control 高度 elevation除去，消除 eliminated经验的 empiric能量 energy必要的，必不可少的 essential优于，擅长 excel专有的 exclusive偏差 excursion实现 execute伸展 expand分离（拆卸）装置 extractor面板，花盘 faceplate特点，特征 feature毛毡 felt铁素体 ferrite铁素体轧钢 ferrite rolling铁素体结构 ferritic填充辊道 fill-in table精轧机出口温度 finisher delivery temperature 精轧机进口温度 finisher entry temperature裂纹 fissure固定导板 fixed guide法兰 flange楔形 flared shape平面液晶显示器 flat-face CRT裂纹 flaw易弯曲的 flexible挠性推爪 flexible dog荧光的 fluorescent尾座 foot stock地脚螺栓 foundation bolt框架 frame全扩展状态 fully expanded漏斗形 funnel级别，钢种 grade晶粒 grain干油 grease磨床 grinder磨，打磨 ground挡板 guard导卫 guide导辊 guide roller导板 guide-liner导向导板 guiding apron旋转 gyrating手轮 hand wheel钩子 hanger床头 head stock高位水箱系统 head tank system集水管 header喷水横梁 header piping保温罩 heat holding cover高速飞剪 high speed strip shear高速穿带装置 high speed strip threading device 绞接 hinge高速转动体 hi-rotor起重机 hoist压紧辊 hold down roll1780热轧生产常用专用英语词汇Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapor cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却Head water tank 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度。

A R steel 高温度锰钢abnormal steel 反常钢; 非正常钢aluminium-steel cable 钢铝电缆aluminized steel 涂铝钢aluminum nickel steel 铝镍钢anchored steel trestle 锚固式钢栈桥angle steel ruler 钢角尺anisotropic steel 各向异性钢片anisotropy silicon steel 各向异性硅钢片annealed sheet steel 退火薄钢板annealed steel 退火钢; 韧钢anti-creeping angle steel 防爬角铁anticorrosive aluminium-coated steel wire 防蚀镀铝钢丝arc-furnace steel 电炉钢arc-welded steel pipe 电弧焊接钢管area of steel 钢筋断面面积; 钢筋截面面积area of structural steel 型钢截面积Armco aluminized steel 阿姆柯渗铝钢armco aluminized steel 表面浸镀铝钢Armco stabilized steel 阿母柯稳定化钢Armco steel 阿姆柯软钢armco steel 不硬化钢austenilic Ni-Cr stainless steel 奥氏体镍铬不锈钢austenitic alloy steel 奥氏体合金钢austenitic chromium-nickel steel 奥氏体铬-镍钢austenitic clad steel 奥氏体复合钢austenitic heat-resistance steel 奥氏体耐热钢austenitic manganese steel 奥氏体锰钢; 哈德菲尔德锰钢austenitic stainless steel 奥氏体不锈钢austenitic steel 奥氏体钢automatic steel 易切削钢automatic(al) steel 易切削钢axle shaft steel 车轴钢axle steel 车轴钢钢铁业的英语词汇1Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Case-Hardened Steel 表面渗碳硬化钢; 渗碳钢Bolts & Nuts For Steel Slotted 角钢螺丝Cast Alloy Steel Piston 合金铸钢活塞Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 铸造不锈钢Cast Steel 铸钢件Cast Steel Plate 铸钢板Cast(Carbon) Steel 铸钢Cast-In Steel Bush 铸入钢套Casement Section Steel 窗框钢Cast-Steel 铸钢Cast-Steel Crossing 铸钢辙叉Cast-Steel Pipe 铸钢管Cast-Steel Separator 铸钢隔板; 铸钢横梁Cast-Steel Shot 钢砂Cast-Steel Yoke 铸钢轭Cellular Steel Floor 格型钢楼板Cement-And-Grouted Steel Bolt 钢筋砂浆锚杆Cemented Steel 表面硬化钢Cemented Templet Steel 渗碳样板钢Centra Steel 球状石墨铸钢Centrifugal Steel 离心铸钢Centrifuge(D) Steel 离心铸造钢Channel Steel 槽钢Channel-Section Steel 槽形钢Channeled-Steel Wheel Rim 槽钢制轮辋Checkered Steel Plate 花纹钢板Chemical Capped Steel 化学封顶钢Chilled Cast Steel 冷硬铸钢Chilled Hardened Steel 淬火钢Chilled Steel 淬火钢; 淬硬钢Chisel Steel 凿钢; 凿子钢Chrome Hardened Steel 铬硬化钢Chrome Steel 铬钢Chrome-Carbon Steel 铬碳钢Chrome-Manganese Nitrogen Steel 铬锰氮钢Chrome-Manganese-Silicon Alloy Steel 铬锰硅合金钢Chrome-Molybdenum Steel 铬钼钢Chrome-Nickel Steel 铬镍钢Chrome-Plated Steel Nozzle 镀铬钢喷管Chrome-Silicon Steel 铬硅钢Chrome-Tungsten Steel 铬钨钢Chrome-Vanadium Steel 铬钒钢Chromemanganese Steel 铬锰钢Chromium Nickel Steel 高强度耐蚀铬镍钢Chromium Stainless Steel 铬不锈钢Chromium Steel 铬钢Chromium-Molybdenum Steel 铬钼钢Chromium-Nickel Steel 铬镍钢Chromium-Plated Mild Steel Animal Chain 镀铬软钢动物链条Chromium-Tungstenvanadium Steel 铬钨钒钢Chromiummanganese Steel 铬锰钢Chromiumnickel Austenite Stainless Steel 铬镍奥氏体不锈钢Chromiumplated Thin-Walled Steel Cylinder Liner 钢质薄壁镀铬汽缸衬套Chromized Steel 渗铬钢Circular Steel Support 环形金属支架Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel 包覆钢Cladding Steel Sheet 复合钢板Clean Steel 纯净钢; 洁净钢Closed Die Steel 闭锻模钢Coarse-Grained Steel 粗晶粒钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧钢Cold-Rolled Carbon Spring Steel 冷轧弹簧碳钢Cold-Rolled Carbon Steel 冷轴碳钢Cold-Rolled Steel Strip 冷轧带钢Cold-Shaping Steel 冷变形钢Cold-Short Steel 冷脆钢Cold-Steel 利器Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Coldshort Steel 冷脆钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Column With Steel Hooping 螺旋箍筋柱Combined Steel And Concrete Column 钢骨混凝土柱Comminuted Steel Shot 钢粉Common Straight Carbon Steel 普通碳素钢Complex Alloy Steel 多元合金钢; 合金钢碳素结构钢Carbon Construction Steel碳素工具钢Carbon Tool Steel合金结构钢Alloy Construction Steel合金工具钢Alloy Tool Steel高速工具钢High Speed Tool Steel弹簧钢Spring Steel不锈耐热钢Stainless & Heat Resisting Steel轴承钢Bearing Steel工字钢Ibeam普通圆钢Round Steel槽钢Channel扁钢Flat Steel Bar等边角钢Equal Angle Steel不等边角钢Unequal Angle Steelh型钢Hbeam钢坯Billet,Bloom钢筋混凝土用变形钢筋High Strength Deformed Steel Bar窗框钢Window Sash中厚钢板Steel Plate热轧钢板（卷）Hot Rolled Steel Coil冷轧钢板（卷）Cold Rolled Steel Sheel or Coil镀锌钢板（卷）Galvanized Steel Coil钢带Steel Strip线材Wire Rod Coil无缝钢管Seamless Steel Pipe锅炉管Boiler Tube石油套管Pipe For Oil Field高压管Pressure Pipe高压气瓶用管Tube for High-Pressure Vessel地质钻探用管Seamless Steel Pipe For Geological Drill In镀锌焊管Galvanized Welded Pipe石油钻探杆Drill Pipe For Oil Field铸铁管Cast Iron Pipe重轨Heavy Rail轻轨Light Rail炼钢生铁Basic Pig Iron铸造生铁foundry Pig Iron普通圆钢钉Round Nails for General Uses 镀锌底碳钢丝Galvanized Low Carbon Steel Wire.钢丝绳Steel Wire Rope钢绞线Stranded Wire预应力混凝土钢丝Steel Wire For Prestressed Concrete 窗纱Window Screen车轮Wheel Tyre轮筛Wheel Circleiron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模(美作:mold) tuyere, nozzle 风口ingot mould 锭模(美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬(美作:blowtorch) crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿(美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型(美作:molding) calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔钢铁业的英语词汇2Abnormal Steel 反常钢; 非正常钢Aluminium-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Anchored Steel Trestle 锚固式钢栈桥Angle Steel Ruler 钢角尺Anisotropic Steel 各向异性钢片Anisotropy Silicon Steel 各向异性硅钢片Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Anti-Creeping Angle Steel 防爬角铁Anticorrosive Aluminium-Coated Steel Wire 防蚀镀铝钢丝Arc-Furnace Steel 电炉钢Arc-Welded Steel Pipe 电弧焊接钢管Area Of Steel 钢筋断面面积; 钢筋截面面积Area Of Structural Steel 型钢截面积Armco Aluminized Steel 阿姆柯渗铝钢Armco Aluminized Steel 表面浸镀铝钢Armco Stabilized Steel 阿母柯稳定化钢Armco Steel 阿姆柯软钢Armco Steel 不硬化钢Austenilic Ni-Cr Stainless Steel 奥氏体镍铬不锈钢Austenitic Alloy Steel 奥氏体合金钢Austenitic Chromium-Nickel Steel 奥氏体铬-镍钢Austenitic Clad Steel 奥氏体复合钢Austenitic Heat-Resistance Steel 奥氏体耐热钢Austenitic Manganese Steel 奥氏体锰钢; 哈德菲尔德锰钢Austenitic Stainless Steel 奥氏体不锈钢Austenitic Steel 奥氏体钢Automatic Steel 易切削钢Automatic(Al) Steel 易切削钢Axle Shaft Steel 车轴钢Axle Steel 车轴钢Bainitic Steel 贝氏体钢Balanced Steel 半镇静钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Bamboo Steel 竹节钢筋Band Steel 带钢Banding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Basic Bessemer Steel 碱性贝氏转炉钢Basic Bessemer Steel 碱性转炉钢Basic Bessemer Steel Converter 碱性转炉钢转炉Basic Converter Steel 碱性转炉钢Basic Electric Furnace Steel 碱性电炉钢Basic Open Hearth Steel 碱性平炉钢Battened Steel Column 双肢钢柱Beam Steel Plate 大梁钢板Beam With Compression Steel 双筋梁Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Bent Steel 挠曲钢筋Bessemer Low Carbon Steel 酸性转炉低碳钢Bessemer Mild Steel 贝色麦钢Bessemer Steel 贝色麦钢; 酸性钢Best Plough Steel Wire 铅淬火高强度钢丝Billet Steel 坯段钢; 钢坯; 短条钢Binary Steel 二元合金钢Black Mild Steel Carriage Bolt And Nut 黑铁马车螺丝闩Black Mild Steel Fish Bolt And Nut 黑铁鱼尾螺丝闩Black Mild Steel Flat Head Rivet 黑铁扁头铆钉Black Mild Steel Flat Head Tinmen Rivet 黑铁号头铆钉Black Mild Steel Hexagonal Nut 黑铁六角螺丝帽Black Mild Steel Pan Head Rivet 黑铁锥头铆钉Black Mild Steel Round Head Rivet 黑铁圆头铆钉Black Mild Steel Square Nut 黑铁四方螺丝帽Black Steel Pipe 黑钢板Black Steel Sheet 黑钢皮Black Tin Steel 黑钢板Blister Steel 泡钢; 泡面钢Abnormal Structure Steel 反常组织钢Abrasion-Resistant Steel 耐磨钢Blue Steel 蓝钢Bluing Of Steel 钢加蓝Boiler Steel 锅炉钢; 锅炉钢板Boiler Steel Plate 锅炉钢板Boiling Steel 沸腾钢Bolting Steel 螺栓钢Blue Planished Steel 发蓝薄钢板Bloom Steel 初轧钢; 钢坯Boron Steel 硼钢Brass Fitting Of Steel Window 钢窗铜配件Brass-Plated Mild Steel Round Bead Wood Screw 镀黄铜圆头软钢木螺丝Brass-Plated Mild Steel Round Head Machine Screw 镀黄铜圆头软钢机器螺丝Brass-Plated Steel Wire 镀黄铜钢丝Brearley Steel 布里阿雷不锈钢; 布氏高铬钢Bridge Steel 桥梁钢Bright And Black Mild Steel Flat Head Tinmen Rivet 号头铆钉Bright Mild Steel Cotter Pin 光亮软钢开尾销Bright Mild Steel Countersunk Head Wood Screw 光亮软钢平头木螺丝Bright Mild Steel Hexagonal Nut 光亮软钢六角螺丝帽Bright Mild Steel Hexagonal Nuts 六角光螺帽; 六角螺丝帽Bright Mild Steel Hexagonal Pressed Nut 光亮软钢六角冲压螺丝帽Bright Mild Steel Round Head Wood Screw 光亮软钢圆头木螺丝Bright-Drawn Free Cutting Steel 光拉自由切削钢Bright-Drawn Steel 光亮拉拔钢材Bright-Finished Steel 光亮精整钢Bristol Steel Belt Lacing 布瑞斯涛钢带接头Bronze Steel 镀青铜钢Building Of Steel Frame Construction 钢框架房屋Bulb Steel 球扁钢Bulb-Rail Steel 球头丁字钢Burned Steel 过烧钢Calorized Steel 涂铝钢; 渗化钢Calorizing Steel 铝化钢Capped Steel 加盖钢; 半镇静钢Carbon And Low-Alloy Steel Vessels 碳钢及低合金钢容器Carbon Content Of Steel 钢含碳量Carbon Molybdenum Steel 钼碳钢Carbon Steel 碳钢; 碳素钢Carbon Steel Covered Electrode 碳钢焊条Carbon Steel Plate。

钢铁⾏业专业英⽂词汇(aluminium) killed steel （铝）镇静钢1b 磅abbreviation 缩写abrasion-resistant 耐磨损的A-C vector driver 交流向量驱动access 使⽤或进⼊之途径，通路accessibility 可达性，可接近性accessory (attachment)accommodate 供应accomplish 完成accumulator 活套accuraccy 准确性，精密性ACFM average cubic feet per minite 平均⽴⽅英尺/分钟1⽴⽅英尺=35.3147⽴⽅⽶acid concentrate 酸浓缩acid contaminate waste water 酸污染废⽔acid fume 酸雾acoustic 听觉的、声学的actual 真实的actuate 开动,使动作,作⽤,励磁acuator 调节器,激活器,执⾏机构adapter 联接器，接合器adequate 充⾜，适当adjacent 邻近的administration ⾏政管理AGC automatic guage controlagency 机构agitation 摇动air box 风箱air compressor 空⽓压缩机air duct 风管，通风管道air oven 热空⽓⼲燥炉algorithm 计算法align 使成⼀条直线，对准，校直alignment 调整，排成直线alkaline 碱的、含碱的alkalinity 碱度allowance 许可，承认，余量alpha/numberic 字母数字混合编排的alternate 交替altitude ⾼度alumize 铝化，渗铝ambience 环境温度ammonia 氨⽓anchor 锚，固定器，⽀座ancillary 辅助的,附属的angle bar 三⾓铁annealing pickle lineannealing treatmentANSI American National Standards Institute美国国家标准协会anticipate 先做，盼望anti-finger steel plate 耐指纹钢板antirust oil 防锈油appertain 所属appliance 器具applicable 适⽤的applicator roll 涂覆辊appropriate 适当的approve 批准，认可，赞成archival 档案的arrangement 排列，布置，配置，装配，安装as-built drawing 竣⼯图ASC automatic shape controlassembly 部件，组件，装置，组装assembly parts 组合件assessment 评价assistance 帮助assume 假定atomize 雾化attain 到达，得到authorize 批准，授权automatic coil bending station 带钢⾃动打捆站auxiliary 辅助的availibility 有⽤的，可资应⽤性，利⽤率，有效性axis 轴back tension 反张⼒back-up roll ⽀撑辊backward curve type fan 后曲叶⽚式风机backward-inclined type fanbaffle plate 挡板banding strap 捆带base frame 底座base strip(plate)batch annealing 罩式退⽕battery limit 界区bay 跨beam 光线，横梁，照射bearing 轴承bearing chockbearing race 轴承座圈bearing-load-distribution 轴承载荷分布bed plate 底板，地脚板（轧机）belt wrapper ⽪带助卷机bench levelbench mark ⽔准点,基准bilateral tradebillet ⽅坯bite 辊缝，咬⼊bivalent ⼆价bladder ⽓囊blade ⼑峰bloom ⼤钢坯、钢锭、初轧⽅坯board 配电盘board chair 董事长bogie 转向架boiler 锅炉，汽锅，蒸煮器boiling steelborer 镗床brace （⽀持，拉紧，振奋）斜撑，⽀柱，系杆，⼿摇钻brake 煞车器，掣动，煞车breaker roll 破鳞辊bridle set 张紧装置bright annealing 光亮退⽕bronze 青铜bronze bushing 青铜轴套BTU British Thermal Unit 英国热量单位 1BTU=262Kbuckle 中间浪,皱,纹buffer 缓冲器bumper 保险杠、消⾳器buna 丁（⼆烯）钠（聚）橡胶，布纳橡胶bundle （光、维管、波）束、捆、扎burr,flash ⽑刺bush(ing) 轴套，轴衬，衬⽡，（电）绝缘套管butt welding 对焊by means of ⽤、、、的办法cable rack 电缆架calcium 钙calibration 标准、校准caliper 卡尺、卡盘；制动卡盘callout 插图的编号calorific ⽣热的cam 凸轮，;偏⼼轮，样板，靠模，仿形板cam roller 凸轮辊camber 翘曲镰⼑弯carbon block 碳精块carbon dioxidecarbon monoxidecarriage 搬运车carry over table 运输辊道carryover-conveyor 转换运输机cartridge 卡盘,暗盒cascade 级联，⼩落瀑casing 套罩、箱外壳、套管cast 熔炼，铸造，铸件，[冶]浇注，铸锭，炉次cast iron 铸铁casting 浇铸catalogue ⽬录，编⽬录catalytic 催化的catenary 悬索，[压]（带钢）垂度，弛度caustic 腐蚀性的cell 光电元件central pipe 中⼼缩孔(缩管)centrifuge 离⼼ceramic 陶瓷chain conveyor 链式运输机check valve 逆⽌阀，⽌回阀chemical constitution 化学成分chloride 氯化物chop 碎断chrome 铬chronological 编年的chute 槽，斜槽，滑槽，溜槽circuit breaker 断路开关，断路器circular shear 圆盘剪circumference force 切向⼒civil work ⼟建clading,film 镀层clam 夹具，台虎钳，钳⼦，夹⼦clamp ⽼虎钳，钳clearance 余隙，间隙，清除，扫除，许可clutch 离合器coarse 粗糙的coefficient 率，系统coil break 横褶纹coil centering 带卷定⼼coil peeler 带卷直头机cold drawn 冷拔Cold Laminator 冷覆膜机cold rolled stripcold tandem millcollapse （坍，崩溃），回缩collapsible 折叠的，胀缩的colour coated stripcolumn 柱⼦，栏，塔，蒸馏塔，萃取塔，吸咐塔combustion 燃烧comment 评注，批评commission 使⽤(试运转)compatible 兼容的compensate 补偿，均衡，校正，（⾦属，合⾦的）调质compensator 膨胀圈,膨胀接头compliance 顺从concentrically 同轴的concrete 混凝⼟condenstate 冷凝，回流conductivity 传导率，电导率，传导性，导电性，导热率conduit box 接线盒consective 连接作⽤consideration 考虑consistent ⼀致的console 控制台，仪表板consortium 合伙constrain 强迫、压制、束缚、约束construct 构造物，建造，构成consume ⽤尽，毁灭contamination 污染、玷污、放射性污染、混淆contour 轮廓线,外形,等⾼线contract 合同，协议contractor ⽴契⼈，承包商control cubicle 控制柜control valve 操纵阀，控制阀convection 对流conversion 转变conversion coating 转换层（辊涂后）convertor 转炉conveyor 运输机，输送机，传送机，移送机coordination 调整,配合corrosive 腐蚀性的corrugate ⽡楞、波纹council 委员会，政务会coupling section 连接部分cover plate 盖板CPL continuous pickling line 连续酸洗⽣产线cradle ⽀架，摇架cradle rolls 托卷辊crate ⼤板条箱，⽤⼤板条箱装crimping 皱褶，波纹crop shear 切头剪cross-tie 枕⽊，轨距，连杆，横向拉杆，横⽊curcuit 电路，回路，系统，流程，循环customs inspection 海关检查cutting gap 剪切间隙CVC continuous variable crown 连续可变凸度cyclone 旋风,离⼼除尘cylinder block 缸组，缸体dam up 筑坝，阻⽌damper 阻尼,缓冲,减震器,风门DC bus 直流母线debrics 碎⽚、屑deburring 去飞边，去⽑刺，去⽑边decarburization 脱碳deck 盖，甲板，桥⾯，台⾯dedicate 供奉，奉献deflector 导向挡板degree of finish,smoothness 光洁度deionize water ⽆离⼦⽔，脱离⼦⽔deliberate 考虑、斟酌delivery coil car 出⼝带卷⼩车delve 挖掘、钻研denominate 命名depict 描绘、描述depletion 消耗，排除deploy 展开、部署、调度deposition 沉积，沉淀，析出designation strip 名牌、标签detergent 清洁剂、除垢剂dethreading 甩尾deviation 偏差,漂移dew point 露点diagnostic 有助于诊断diaphragm 隔板、挡板、孔板differential 微分discharge pipe 排出管disconnect 拆开，使分开（离）disconnected-switch 隔离开关discreeet 考虑周到的，谨慎的discrepancy 不同disengage 解脱，松开Disk Brake 盘式制动器dismantling stooldissipation 消散,消耗,损耗distill 蒸馏除去distribution thansformer 配电变压器dividing shear 切分剪downpayment 定⾦drainage 排⽔,阴沟draw off 抽取，排泄drive spindle 传动轴drop separatordrum 圆筒，⿎drum shear 滚筒剪duct 管道ductile 可延伸的ductile iron casting 球墨铸铁件due time 到期durability 耐久duty-cycle ⼯作循环，⼯作周期dynamically balanced 动平衡economic benefiteddy-current test 涡流探伤edge drop 边部减薄EDM=Electron Discharge Machining 放电加⼯EDPM 三元⼄丙橡胶elaborate 详细拟定elapse 过去、消逝elastic constantelastic deformation 弹性畸变electrical room 主电室elevation ⾼度，⾼处，提升，正⾯图，⽴式图elevator 升降机，电梯elongation percentage 延伸率embed 安插，埋置Embosser 热压花机empiric 根据经验的emptying 沉淀物emulsion 乳剂encapsulation 密封、包胶enclosed speed reducer 全封闭的减速机enclosure 套，盒，箱，包围，围绕，封⼊，外壳endless belt 两头对接的环带endurance 耐久⼒endurance limit (fatigu limit ) 持久极限，疲劳极限engage （齿轮）啮合，使紧密联接ensure 保证entry guid ⼊⼝导轨EPOXY Resin (EP) 环氧树脂equalizer 均衡器equivalent 当量，等效值erection schedule 安装进度erection supervision assistance 制造监理ergonomic ⼈体⼯学、⼯效学、⼈与机械控制ethernet 以太⽹evaporator 蒸发器eveness 均整性evolve 发展、进化、离析、引申excavation 挖掘excentricity 偏⼼exclusion 排斥exert 发挥,尽⼒expanding cylinder 膨胀缸expansible coil preparatory coiler 胀缩卷筒式带材预卷机explosion 爆炸explosion proof lighting 防爆照明extractor 提取、萃取器、抽提塔extrusion 挤压fabricate 构造、建造、杜撰fabricate 建造fabricated steel construction 预制钢结构Fabricated Frame 预制钢结构facilitate 使变的容易的，促进factor 系数，因素，因⼦，因数，乖数feed table 进料盘feed-forward 前馈ferritic 铁素体ferrous 含铁的、铁素体的festoom 花彩、垂花饰fillet （模型或芯盒上的）圆⾓条，倒圆⾓，嵌条finishing coat ⾯漆finishing machining 精加⼯finite element method 有限元法fittings 配件，连接件，零件，器材，仪器fixture 设备，夹具，装置器flange 法兰flap ⽚状悬物,舍阀,舍flattener roll 矫直辊flexible 伸缩⾃如的，柔性的float valve 浮筒阀flowrate 流量，流速FLT full load torquefluctuation 波动、摆动flue gas 烟⽓fluid 流体fluorocarbon 碳氟化合物flying crank shear 曲柄式飞剪FOB freight on board 离岸价格foil 压薄、薄⽚forged 锻造的fork lift 叉车foundation 地基，基础fracture 破裂、断⼝friction 摩擦friction factorFSIR full spectrum infraredfuel 燃料fulcrum ⽀点fused switch 熔断开关galvanized sheetgangway 通道,过桥gap 辊缝gasket 衬垫，垫圈gauge 规格，估计，量规计gear case 减速箱壳gear rack 齿条girder 梁,垳架gloss range 光泽度范围gradient 梯度granite 花岗岩grate 铁栅栏，格栅grease lubrication ⼲油润滑grid 栅格grinder,grinding machine 磨床grit blast, spray sand 喷砂，喷丸groove 凹槽gross 总重grounding cables 接地线grout 灌浆guard 保卫，防护，挡板gutter 阴沟、⽔槽hand railing 扶⼿，栏杆hand-over position 交接区harmonic 谐波headquarter 总部、司令部heat expantionheating furnace 加热炉helical 螺旋的，螺线，螺旋线（⾯，形，状）helid 氦化物heoprene 氯丁（⼆烯）橡胶hermetical 密封的herringbone ⼈字形hierarchical 阶级的high dynamically loaded bolt ⾼强螺栓high order ⾼位,⾼次high pressure hot waterhinge 铰链、铰接histogram 直⽅图historical 史学的hoist 起重机hold-down roll 压紧辊homogeneity 同质、均匀性、齐次homogeneous 同族的、单⼀的、同次的hood 罩，盖，帽，烟罩，通风，橱horn 警报器hose 软管，⽤软管引⽔hot rolled striphousehold [electrical] appliance 家电housing 框架HTR High Tech Rolling humidity 潮湿hung 悬挂了hydralic bolt tightener 液压扳⼦hydralic screwdown 液压压下hydraulic accummilator 蓄能器hydraulic cylinder 油缸hydridehydrochloric acid 盐酸hydrogen 氢⽓hydrostatic lubrication 静液压润滑hypalon 氯磺化聚⼄烯橡胶hypothesis 假设hysteresis 滞后I.D. indetification idle roller 空转轮，惰轮ignition hood 点⽕器immersion cell 沉浸槽impact 撞击impart 分给impeller 推动者（器）叶轮impinging flow 射流in accordance with 依据inaccessible 达不到的，难接近的incorporate 合并indication 表⽰，象征indispensable 不可缺少individually 单独地inductive 电感，归纳（法）的inert gas arc welding 惰性⽓体保护(弧)焊inertia 惯性，惯量infrared ray 红外线ingot （铸）锭inhibit 制⽌，禁⽌initiate 引发，使⼊会，开始inlet side ⼊⼝侧inspection 视察，检查instrumentation 器械操作，仪器，仪表insulation 绝缘，绝热integrate 整合，集成intensity 强度，强烈，剧烈interchangeability 可交换性，互换性intercom 室内对讲对话，内部通信装置interconnecting piping 连通管路interface 接⼝interlock 连索互结intermediate roll 中间辊interrogate 询问、质问intervention 介⼊、调停、⼲涉inverter 换流器，变换器，反相器，转换开关ionize 电离isolating transformer 隔离变压器isolation transformer 隔离变压器jack scraw 千⽄顶螺杆，起重螺杆joint shaft 接轴junction box 汇接室，分线箱，接线盒，套管，连轴器keeper plate 轧辊轴承座压板kick off meeting ⾸次会议L/C lisence credit 信⽤证laminar 层⽚、叶⽚lap welder 搭接焊lateral 侧⾯的layout 布置，规划，设计lean gas 贫（瘦、⼲、废）（煤）⽓least square 最⼩⼆乘ledge 横档，壁架levelling instrument ⽔准仪light-gauge 薄尺⼨lightning 雷,闪电limb of electromagnet 电磁铁铁⼼limit switch 极限开关，终点开关linkage 连接，链系，联动装置，杠杆机构liquid nitrogen 液氮lithium chloride 氯化锂load cell 测压仪，测⼒计，发送器loading skid 装载滑轨lockout relay 连锁继电器longitudinal 轴向的，长度的lower limit of strengthLPG liquefied petroleum gas 液化⽯油⽓machinical propertymagnitude ⼤⼩，数量，等级make-up air 补给空⽓malfunction 不正常⼯作、动作失调mandrel diameter 芯轴直径manhole （检修⽤）⼈孔，检查孔，舱⼝manifold 集管,多头导管marine 海的，海（磨、冲）蚀martensitic 马⽒体masher 捣碎mashine steel 机械（零件）⽤钢(0.2-0.3C) mass moment of inertia 质量惯性矩mass ratio 始末质量⽐mass/volume flow control (VFC)质量流控制matrix 矩阵，发源地，模型mature 成熟的measuring staff(rod) 测量棒mechanism 机构，机械装置，机理melting point 熔点metallurgy 冶⾦学metastable 亚稳定mezzaine 夹层、中层楼mica 云母mild steel 低碳钢mill length 轧制长度miller 铣床misalignment （中⼼线）未对准，不重合，mitigate 减轻、缓和moment 矩,动量Monorail Structure 单轨结构件Morgoil bearing 油膜轴承mortar 灰浆Mota 锡基⾼强度轴承合⾦mould typemounting 装置MTBF mean time between failure平均故障影响时间muffler 消声器multiple 多重的，复合的，倍数naphthalene 萘NEMA National Electrical Manufacturers Association（美国）全国制造商协会neoprene 氯丁橡胶、氯丁⼆烯niobium[nai5EubiEm] 铌nip 咬⼊、辊隙nipple 喷嘴,螺纹接套nitrile 丁腈橡胶nom 公（标）称nominal value 额定值、标称值normalise 正⽕notch 缸⼝，刻痕，凹槽，嘴⼦numeric 数字，数值，分数，不可通约数obstruction 阻碍、妨碍occupational 职业的off-load 卸载optimum 最好条件option 挑选物，选择，选择权organic 有机的orifice 洞，孔orifice meter 孔板流量计O-ring seal 圆环密封ovality 椭圆度oven inner liner 加热炉内衬over picklingoverhead craneoverhung 悬垂的overlap 重叠overspill 溢出，溢出物，溢流，[机]排出润滑油overwind 上开卷oxideoxygenp.f. power factor 功率因数packing 包扎，打捆，填料，衬料pad 底垫，衬垫，垫料，垫⽚，垫圈padlock 挂锁paint 漆panel 板，盘，屏，开关板，控制板，配电盘parabolic 抛物线parallel 平⾏的，相同的parameter tableparticulate 粒⼦parting shearpass 孔型,轧槽,道次pass line 轧线patent 专利pay-off coiler 开卷机pay-off cradle 开卷箱座pay-off drum 开卷机卷筒pay-off housing 开卷机机架pay-off reel 开卷机penertation 渗透permanent 永久的permit [环保](废物排放)许可证perpendicular 直⽴的，垂直的personnel ⼈员，职员pertiment 适当的、贴切的、相应的petroleum ⽯油phenolic (苯)酚photocell 光电元件photo-electric 光电（效应）的PI diagram piping and instruments diagram pickling bath 酸洗槽piling 打桩pillar ⽀柱、墩pillow block 枕垫、垫块pilot flame 引燃⽕⾆pilot valve 导阀,辅助阀,控制阀pin 针，销，细杆，旧棒pinion 传动齿轮，⼩齿轮piston rod 活塞杆pivot 轴尖、枢轴pivotable guide table 绕枢轴旋转的导板台planer 刨床plasticityplatform 场，平台，站台，装卸台plausibility 似乎合理plot 绘图、曲线、地块plug 塞⼦ply 层，厚度plywood 夹板，层板pneumatic ⽓动polypropylene 聚丙烯polyurethane 聚氨基甲酸（⼄）酯portuguese 葡萄⽛的（⼈）positive 明确的，正的，阳性的PP pressure-proof 耐压的PP plastic product 塑料制品pre-assembly method 预置装配法precise 精确的preliminary 初步，开端pressductor 压⼒传送器pressure reducer 减压阀pressure switch 压⼒开关，压⼒继电器pressurization 加压prevail 成功，流⾏，胜过primer 底漆primer base 底漆涂料prior 在先的procurement 采购,获得profile 板形property 性质proprietary 专利的province 职权范围provision 供应，规定，预备proximity switch 接近开关PTFE 聚四氟⼄烯pulley 滑轮,滚筒purchase 换取，购买purge 吹扫、清洁pushbotton 按钮，电钮pvc (polyvingl chloride ) 聚氯⼄烯quarter 1/4 浪quench 淬⽕quenching and temperingrack 架⼦，齿轨rack-and-pinion 齿轮齿条rate 估价，⽐率rated 额定的，标准的reaction equation 反应⽅程式reactive power ⽆功功率recess 凹进处，凹⼝，凹槽，退⼑槽recovered acid 回收的酸rectifier [电]整流器，检波器recuperate 回收、余热利⽤redundant system 冗余系统reel mandrel 卷筒reflective 反射的regressive 回归regulation 规则，管理regulator 调节器，调节装置，稳定器reinforced concret 钢筋混凝⼟relative humidity 相对湿度release 释出，解除联锁断开relief valve 安全阀，保险阀remote I/O rack 远程输⼊／输出机柜removal 移动reserve volume 储备量reservior 容器、贮⽔池、⽔箱residul error 残留误差resistance of deformationresonant frequency 谐振频率responsibility 任务，责任rest ⽀撑retention 保留，滞留（物）retract 伸缩revamping 修补、改造reversible 可逆的rewind 重卷，重绕ridge 屋脊、⼭脊rigid 刚性rigidity 刚性rinse 冲洗，轻冼RMS root mean square value均⽅根，有效值roll barrel 滚⾝roll bearing 轧辊轴承roll neck 辊颈roll wear 轧辊磨损roller bearing 滚柱轴承roller chain 辊⼦链rolling radius 轧制半径rolling schedule 轧制程序表rolling solution 轧制⼯艺润滑冷却液rolling speedrolling stock 机动车辆,轧制⽑坯rope pulley 绳轮rough machining 粗加⼯roughness 粗糙度rubber lining 橡胶衬⾥saddle 马鞍，鞍状物safety coupling 安全连轴器safety guard 安全设施，保险板sample preparetion 取样sanitary 公共卫⽣的,消毒的,公共厕所satisfactory 今⼈满意的saturation 浸透，饱合，饱合状态scaffold 脚⼿架scale exhaust 除鳞scale layer 鳞层schematic drawing ⽰意图,结构图,原理图scrap bucket 废料⽃（槽）scratch 擦痕screw down 螺旋压下机构screw jack 螺旋千⽄顶scrubber 洗涤器seal 封闭seamless ⽆缝的，整拉的sectional steel 型钢segment ⼸形体，扇形体，段，节，⽚seismic coefficient 地震系数self-commuted ⾃换向self-tuning ⾃调seperating disc 分离圆盘service factorService Hoist 电葫芦shallow tank 浅槽shield 防护，屏蔽，护罩shield gasshift 移动shim 垫⽚shock absorber 减震器shrink 收缩，退缩，缩⽔shroud 罩shuttering 模板shuttle 棱，来回移动sickle shaped 镰⼑弯side guide 侧导轨side trimming 齐边side-set cylinder 横移液压缸sight 观察silicon dioxidesilicone modified polyester 硅改性树脂sinter plant 烧结⼚skew 斜、不对称Skew/Synchromous Run Controlskid 刹车，刹着车滑⾛slab casting 板坯连铸slabing 板坯sleeve 套筒slice 薄⽚slide vavle 滑阀sliding base 导向轨座（机座可以沿其移动）sliding frame 滑座sling 吊索slitting shear 纵切slope 坡道，斜⾯，坡度，斜度sludge 淤泥、残渣SMPS switch-mode power supply开关电源snubber roll 缓冲辊,减震辊,抱辊soleniod valve 电磁阀solution treatment 固溶处理spangle 锌花spare part 备件spark-ignited 电⽕花点⽕specific weight ⽐重specification 规格，说明书spectrum 谱、光谱speed cone 变速锥spindle carrier 接轴托架spindle nose 轴头spiral conveyor 螺旋型运输机splash 飞溅splice 接合、拼合split-out 分交spray-off 喷射spring equation 弹跳⽅程sprocket 链（星）轮、链轮铣⼑squeezing roll 挤⼲滚stage 步骤，时期，阶段stagger 交错、间隔stainless steel construction 不锈钢结构stairway 楼梯stand-by 备⽤。

钢铁行业常用英语词汇钢铁行业常用英语词汇Austenitic Stainless Steel 奥氏体不锈钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Band Steel 带钢Banding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Abrasion-Resistant Steel 耐磨钢forge 锻造press 压锻alumina 铝cast iron 铸铁cast iron ingot 铸铁锭soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭round iron 圆铁scrap iron 废铁steel 钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品metal strip, metal band 铁带,钢带billet 坯锭,钢坯profiled bar 异型钢材shape, section 型钢angle iron 角钢wire 线材ferronickel 镍铁fusion, melting, smelting 熔炼refining 精炼heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦carburization 渗碳case hardening 表面硬化cementation 渗碳nitriding渗氮alloy 合金rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝forging 锻造turning 车削milling 铣削machining, tooling 加工arc welding 电弧焊electrolysis 电解blowhole 气孔Aluminium-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Angle Steel Ruler 钢角尺Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Common Straight Carbon Steel 普通碳素钢Complex Alloy Steel 多元合金钢; 合金钢Carbon Construction Steel碳素结构钢Carbon Tool Steel碳素工具钢Alloy Construction Steel合金结构钢Alloy Tool Steel合金工具钢High Speed Tool Steel高速工具钢Spring Steel弹簧钢Stainless & Heat Resisting Steel不锈耐热钢Bearing Steel轴承钢Ibeam工字钢Round Steel普通圆钢Channel槽钢Flat Steel Bar扁钢Equal Angle Steel等边角钢Unequal Angle Steelh不等边角钢Hbeam型钢Billet,Bloom钢坯Steel Plate中厚钢板Hot Rolled Steel Coil热轧钢板（卷）Cold Rolled Steel Sheel or Coil冷轧钢板（卷）Galvanized Steel Coil镀锌钢板（卷）Steel Strip钢带Wire Rod Coil线材Seamless Steel Pipe无缝钢管Pressure Pipe高压管Basic Pig Iron炼钢生铁foundry Pig Iron铸造生铁Steel Wire Rope钢丝绳Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 铸造不锈钢Chilled Hardened Steel 淬火钢Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel Sheet 复合钢板Clean Steel 纯净钢; 洁净钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧。

Carbon Steel Plate 碳素钢板; 碳素钢板和型材 Carbon Tool Steel 碳⼯具钢; 碳素⼯具钢 Carbon-Containing Alloy Steel 含碳合⾦钢 Carbon-Free Stainless Steel ⽆碳不锈钢 Carbon-Free Steel ⽆碳钢 Carburizing Steel 碳钢 Case-Hardened Steel 表⾯渗碳硬化钢; 渗碳钢 Bolts & Nuts For Steel Slotted ⾓钢螺丝 Cast Alloy Steel Piston 合⾦铸钢活塞 Cast Iron Electrode With Steel Core 钢芯铸铁焊条 Cast Stainless Steel 铸造不锈钢 Cast Steel 铸钢件 Cast Steel Plate 铸钢板 Cast(Carbon) Steel 铸钢 Cast-In Steel Bush 铸⼊钢套 Casement Section Steel 窗框钢 Cast-Steel 铸钢 Cast-Steel Crossing 铸钢辙叉 Cast-Steel Pipe 铸钢管 Cast-Steel Separator 铸钢隔板; 铸钢横梁 Cast-Steel Shot 钢砂 Cast-Steel Yoke 铸钢轭 Cellular Steel Floor 格型钢楼板 Cement-And-Grouted Steel Bolt 钢筋砂浆锚杆 Cemented Steel 表⾯硬化钢 Cemented Templet Steel 渗碳样板钢 Centra Steel 球状⽯墨铸钢 Centrifugal Steel 离⼼铸钢 Centrifuge(D) Steel 离⼼铸造钢 Channel Steel 槽钢 Channel-Section Steel 槽形钢 Channeled-Steel Wheel Rim 槽钢制轮辋 Checkered Steel Plate 花纹钢板 Chemical Capped Steel 化学封顶钢 Chilled Cast Steel 冷硬铸钢 Chilled Hardened Steel 淬⽕钢 Chilled Steel 淬⽕钢; 淬硬钢 Chisel Steel 凿钢; 凿⼦钢 Chrome Hardened Steel 铬硬化钢 Chrome Steel 铬钢 Chrome-Carbon Steel 铬碳钢 Chrome-Manganese Nitrogen Steel 铬锰氮钢 Chrome-Manganese-Silicon Alloy Steel 铬锰硅合⾦钢 Chrome-Molybdenum Steel 铬钼钢 Chrome-Nickel Steel 铬镍钢 Chrome-Plated Steel Nozzle 镀铬钢喷管 Chrome-Silicon Steel 铬硅钢 Chrome-Tungsten Steel 铬钨钢 Chrome-anadium Steel 铬钒钢 Chromemanganese Steel 铬锰钢 Chromium Nickel Steel ⾼强度耐蚀铬镍钢 Chromium Stainless Steel 铬不锈钢 Chromium Steel 铬钢 Chromium-Molybdenum Steel 铬钼钢 Chromium-Nickel Steel 铬镍钢 Chromium-Plated Mild Steel Animal Chain 镀铬软钢动物链条 Chromium-Tungstenanadium Steel 铬钨钒钢 Chromiummanganese Steel 铬锰钢 Chromiumnickel Austenite Stainless Steel 铬镍奥⽒体不锈钢 Chromiumplated Thin-Walled Steel Cylinder Liner 钢质薄壁镀铬汽缸衬套 Chromized Steel 渗铬钢 Circular Steel Support 环形⾦属⽀架 Clad Sheet Steel 包层薄钢板 Clad Steel 包层钢; 双层钢; 双⾦属钢 Clad Steel Plate 复合钢板 Cladding Steel 包覆钢 Cladding Steel Sheet 复合钢板 Clean Steel 纯净钢; 洁净钢 Closed Die Steel 闭锻模钢 Coarse-Grained Steel 粗晶粒钢 Coated Steel 镀层钢板 Coating Steel Pipe 镀锌钢管 Cobalt High Speed Steel 钴⾼速钢 Cobalt-Chromium Steel 钴铬钢 Coiled Steel 成卷带钢 Cold Forging Steel 冷锻钢 Cold Pressed Steel 冷压钢 Cold Reduced Steel 马⼝铁卷板 Cold Rolled Ribbed Steel Bar 冷轧⽵节钢筋 Cold Rolled Sheet Steel 冷轧薄钢板 Cold Twisted Steel Bar 冷扭钢筋 Cold-Banded Steel Pipe 冷箍钢管 Cold-Drawn Steel 冷拔钢; 冷拉钢 Cold-Drawn Steel Pipe 冷拉钢管 Cold-Drawn Steel Tube 冷拉钢管 Cold-Finished Steel 冷加⼯精整钢 Cold-Pressed Sheet Steel 冷压薄钢板 Cold-Pressed Steel Plate 冷压钢板 Cold-Pressing Quality Steel 冷弯钢 Cold-Roll Steel Sheets 冷轧钢板 Cold-Rolled (Cold Rolled) Steel 冷轧钢 Cold-Rolled Carbon Spring Steel 冷轧弹簧碳钢 Cold-Rolled Carbon Steel 冷轴碳钢 Cold-Rolled Steel Strip 冷轧带钢 Cold-Shaping Steel 冷变形钢 Cold-Short Steel 冷脆钢 Cold-Steel 利器 Cold-Strip Steel 冷轧带钢 Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机 Cold-Worked Steel 冷作钢 Cold-Working Steel 冷作钢 Coldshort Steel 冷脆钢 Color Stainless Steel 彩⾊不锈钢 Colored Stainless Steel 彩⾊不锈钢 Column With Steel Hooping 螺旋箍筋柱 Combined Steel And Concrete Column 钢⾻混凝⼟柱 Comminuted Steel Shot 钢粉 Common Straight Carbon Steel 普通碳素钢 Complex Alloy Steel 多元合⾦钢; 合⾦钢 emptier 排空装置 trough 铁⽔沟,排渣沟 skip 料车 rolling mill 轧机,轧钢机 blooming mill 初轧机 roller 辊 bed 底座 rolling-mill housing 轧机机架 drawbench 拔管机,拉丝机 drawplate 拉模板 shaft furnace 竖炉 refining furnace 精炼炉 reerberatory furnace 反射炉 hearth furnace 床式反射炉 firebrick lining 耐⽕砖衬 retort 反应罐 muffle 马弗炉 roof, arch 炉顶 forge 锻造 press 压锻 pile hammer 打桩锤 drop hammer 落锤 die 拉模 blowlamp 吹炬 (美作:blowtorch) crusher 破碎机 iron ore 铁矿⽯ coke 焦炭 bauxite 铁钒⼟ alumina 铝 cryolite 冰晶⽯ flux 熔剂 limestone flux ⽯灰⽯溶剂 haematite ⾚铁矿 (美作:hematite) gangue 脉⽯ cast iron 铸铁 cast iron ingot 铸铁锭 slag 炉渣 soft iron 软铁 pig iron ⽣铁 wrought iron 熟铁 iron ingot 铁锭 puddled iron 搅炼熟铁 round iron 圆铁 scrap iron 废铁 steel 钢 crude steel 粗钢 mild steel, soft steel 软钢,低碳钢 hard steel 硬钢 cast steel 坩埚钢,铸钢 stainless steel 不锈钢 electric steel 电⼯钢,电炉钢 high-speed steel ⾼速钢 moulded steel 铸钢 refractory steel 热强钢,耐热钢 alloy steel 合⾦钢 plate, sheet 薄板 corrugated iron ⽡垅薄钢板 tinplate, tin 马⼝铁 finished product 成品,产品 semifinished product 半成品,中间产 R steel ⾼温度锰钢 abnormal steel 反常钢; ⾮正常钢 aluminium-steel cable 钢铝电缆 aluminized steel 涂铝钢 aluminum nickel steel 铝镍钢 anchored steel trestle 锚固式钢栈桥 angle steel ruler 钢⾓尺 anisotropic steel 各向异性钢⽚ anisotropy silicon steel 各向异性硅钢⽚ annealed sheet steel 退⽕薄钢板 annealed steel 退⽕钢; 韧钢 anti-creeping angle steel 防爬⾓铁 anticorrosie aluminium-coated steel wire 防蚀镀铝钢丝 arc-furnace steel 电炉钢 arc-welded steel pipe 电弧焊接钢管 area of steel 钢筋断⾯⾯积; 钢筋截⾯⾯积 area of structural steel 型钢截⾯积 Armco aluminized steel 阿姆柯渗铝钢 armco aluminized steel 表⾯浸镀铝钢 Armco stabilized steel 阿母柯稳定化钢 Armco steel 阿姆柯软钢 armco steel 不硬化钢 austenilic Ni-Cr stainless steel 奥⽒体镍铬不锈钢 austenitic alloy steel 奥⽒体合⾦钢 austenitic chromium-nickel steel 奥⽒体铬-镍钢 austenitic clad steel 奥⽒体复合钢 austenitic heat-resistance steel 奥⽒体耐热钢 austenitic manganese steel 奥⽒体锰钢; 哈德菲尔德锰钢 austenitic stainless steel 奥⽒体不锈钢 austenitic steel 奥⽒体钢 automatic steel 易切削钢 automatic(al) steel 易切削钢 axle shaft steel 车轴钢 axle steel 车轴钢 碳素结构钢Carbon Construction Steel 碳素⼯具钢Carbon Tool Steel 合⾦结构钢Alloy Construction Steel 合⾦⼯具钢Alloy Tool Steel ⾼速⼯具钢High Speed Tool Steel 弹簧钢Spring Steel 不锈耐热钢Stainless & Heat Resisting Steel 轴承钢Bearing Steel ⼯字钢Ibeam 普通圆钢Round Steel 槽钢Channel 扁钢Flat Steel Bar 等边⾓钢Equal Angle Steel 不等边⾓钢Unequal Angle Steelh 型钢Hbeam 钢坯Billet,Bloom 钢筋混凝⼟⽤变形钢筋High Strength Deformed Steel Bar 窗框钢Window Sash 中厚钢板Steel Plate 热轧钢板（卷）Hot Rolled Steel Coil 冷轧钢板（卷）Cold Rolled Steel Sheel or Coil 镀锌钢板（卷）Galanized Steel Coil 钢带Steel Strip 线材Wire Rod Coil ⽆缝钢管Seamless Steel Pipe 锅炉管Boiler Tube ⽯油套管Pipe For Oil Field ⾼压管Pressure Pipe ⾼压⽓瓶⽤管Tube for High-Pressure essel 地质钻探⽤管Seamless Steel Pipe For Geological Drill In 镀锌焊管Galanized Welded Pipe ⽯油钻探杆Drill Pipe For Oil Field 铸铁管Cast Iron Pipe 重轨Heay Rail 轻轨Light Rail 炼钢⽣铁Basic Pig Iron 铸造⽣铁foundry Pig Iron 普通圆钢钉Round Nails for General Uses 镀锌底碳钢丝Galanized Low Carbon Steel Wire. 钢丝绳Steel Wire Rope 钢绞线Stranded Wire 预应⼒混凝⼟钢丝Steel Wire For Prestressed Concrete 窗纱Window Screen 车轮Wheel Tyre 轮筛Wheel Circle iron and steel industry 钢铁⼯业 ironworks 铁⼚ foundry 铸造车间 steelworks, steel mill 钢⼚ coking plant 炼焦⼚ electrometallurgy 电冶⾦学 powder metallurgy 粉末冶⾦学 blast furnace ⿎风炉 mouth, throat 炉⼝ hopper, chute 料⽃ stack 炉⾝ belly 炉腰 bosh 炉腹 crucible 炉缸 slag tap 放渣⼝ taphole 出铁⼝,出渣⼝ pig bed 铸床 mould 铸模 (美作:mold) tuyere, nozzle 风⼝ ingot mould 锭模 (美作:ingot mold) floor 平台 hearth 炉底 charger 装料机 ladle 铁⽔包,钢⽔包 dust catcher 除尘器 washer 洗涤塔 conerter 转炉 hoist 卷扬机 compressor 压缩机 tilting mixer 可倾式混铁炉 regenerator 蓄热室 heat exchanger 热交换器 gas purifier 煤⽓净化器 turbocompressor 涡轮压缩机 burner 烧嘴 cupola 化铁炉,冲天炉。

热轧生产常用专用英语词汇2008-12-29 09:53Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapour cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却3Head water tunk 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统5Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊7Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Saddle 鞍座Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度MPM: meter per minute 米/分钟Torque 扭矩Rated torque 额定扭矩Voltage 电压Process computer 过程计算机Program 程序，编程PLC： programmable logic controller 可编程控制器Encoder 编码器Information 信息Ghost rolling 模拟轧制Measuring instrument 测量仪表X-ray X射线Thickness gauge 测厚仪Width gauge 测宽仪HMD: hot material detector 热金属探测仪CMD: cold material detector 冷金属探测仪Light barrier 光栅Automatic model 自动模式Semi-auto model 半自动模式Manual model 手动模式Emergency 紧急，急停Joggle 点动HMI：human machine interface 人机界面AC frequency converter 交流变频器I/O： input/output 输入/输出端口Step control 卷取机助卷辊的“踏步”控制Hydraulic system 液压系统Grease 甘油Oil 油，稀油Oil station 油站9SSC: Short stroke control 短行程控制AGC: automatic gauge control 自动压下控制AWC: automatic width control 自动宽度控制Pump 泵Screw pump 螺杆泵Filter 过滤器，滤网Cylinder 液压缸，圆柱体Valve stand 阀台Accumulator 蓄能器Leakage 泄漏Product 产品Grade 钢种Batch 一炉，一批Batch No. 炉批号Coil 钢卷Strip 带钢，薄带钢Sheet 钢板，薄钢板Plate 中厚板Physical performance 物理性能Mechanical performance 机械性能Strength 强度Elongation 延伸Flatness 平直度Plasticity 塑性Crown/chamber 凸度Hardness 硬度Microstructure 微观组织结构Austenite 奥氏体Ferrite 铁素体Pearlite 珠光体Deep drawn 深冲SPHC 普通级热轧钢板（卷）SPHD 深冲级热轧钢板（卷）SPCC 普通级冷轧钢板（卷）SPCD 深冲级冷轧钢板（卷High strength low-alloy steel 低合金高强度钢Silicon steel 硅钢，电工钢Galvanizing 镀锌Coating 涂镀，涂层Heat treatment 热处理Aging 时效处理Annealing 退火Quenching 淬火OtherAlarm 报警Anchoring bolt 地脚螺栓Yield 产量，成材率Ton 吨Annual 一年的Month 月11Day 日Shift 班Safety 安全Radioactive hazard 放射性伤害Caution 注意，小心Layout 平面布置Document 文件Documentation 技术文本，技术文件报价书TOP: take-over point 交接点4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes 统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes 化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus13共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution 相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet15液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion 菲克第一扩散定律Fick’s 2nd law of diffusion 扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace炼钢钢steel炼钢steelmaking17钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice19单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance 蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,VAR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制 long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping铸铁cast iron熟铁wrought iron电解铁electrolytic iron21白口铸铁white cast iron灰口铸铁grey cast iron麻口铸铁mottled cast iron变性铸铁modified cast iron孕育铸铁inoculated cast iron冷硬铸铁chilled cast iron球墨铸铁nodular cast iron蠕墨铸铁vermicular cast iron可锻铸铁malleable cast iron半可锻铸铁semi-malleable cast iron奥氏体铸铁austenitic cast iron贝氏体铸铁bainitic cast iron共晶白口铁eutectic white iron亚共晶白口铁hypoeutectic white iron过共晶白口铁hypereutectic white iron结构钢constructional steel软钢mild steel普通碳素钢plain carbon steel正火钢normalized steel热轧钢hot rolled steel高强度低合金钢high-strength low-alloy steel 微合金钢micro-alloy steel冷轧钢cold rolled steel深冲钢deep drawing steel双相钢dual phase steel渗碳钢carburizing steel渗氮钢nitriding steel调质钢quenched and tempered steel超高强度钢ultra-high strength steel不锈钢stainless steel奥氏体不锈钢austenitic stainless steel铁素体不锈钢ferritic stainless steel马氏体不锈钢martensitic stainless steel双相不锈钢duplex stainless steel马氏体时效钢maraging steel耐蚀钢corrosion-resisting steel耐热钢heat-resisting steel弹簧钢spring steel易切削钢free-machining steel耐磨钢abrasion-resistant steel工具钢tool steel高速钢high-speed steel冷作模具钢cold-work die steel热作模具钢hot-work die steel钢筋钢reinforced bar steel钢轨钢rail steel轮箍钢type steel管线钢pipe line steel锅炉钢boiler steel电工钢electrical steel∧-shaped segregation倒V形偏析∨-shaped segregation V形偏析1 mass% solution standard质量１％溶液标准(态) abrasion resistance耐磨损性abrasion-resistant steel耐磨钢absorption吸附absorption吸收accelerated melting by coal-oxygen burner氧煤助熔acid open-hearth furnace酸性平炉acid oxide酸性氧化物acid refractory [material] 酸性耐火材料acid slag酸性渣activation energy活化能activity coefficient活度系数activity活度addition reagent添加剂adiabatic process绝热过程adjustable mold调宽结晶器after blow后吹agglomeration团聚aim carbon目标碳air bottom-blown acid converter酸性空气底吹转炉air bottom-blown basic converter碱性空气底吹转炉air gap空气隙air mist spray cooling气水喷雾冷却akermanite镁黄长石Al2O3-SiC-C brick氧化铝-碳化硅-炭砖alumina carbon brick 铝炭砖alumina chrome brick铝铬砖alumina magnesia brick铝镁炭转alumina氧化铝aluminium bullet shooting, ABS 铝弹脱氧法aluminosillicate refractory硅酸铝质耐火材料aluminothermic process, thermit process铝热法amorphous carbon无定形碳amphoteric两性氧化物andalusite红柱石23andradite钙铁榴石anion阴离子annual mine output矿山年产量anode阳极anorthite钙长石apparent activation energy表现活化能arc bias 偏弧argon-oxygen decarburization process, AOD氩氧脱碳法Arrhenius equation阿伦尼乌斯方程arrival at mine full capacity矿山达产Arved lance carbon injection process, ALCI顶枪喷煤粉炼钢法asbestos石棉ASEA-SKF process电弧加热电磁搅拌钢包精炼法austenitic cast iron奥氏体铸铁austenitic stainless steel奥氏体不锈钢back pour, back feeding补浇bainitic cast iron贝氏体铸铁baling of scrap废钢打包ball growth by assimilation生球长大同化机理ball growth by coalescence生球长大聚合机理ball growth by layering生球长大成层机理ball mill球磨机balling disc圆盘造球机balling drum圆筒造球机balling index for iron ore concentrates精矿成球指数banking for coke oven焦炉焖炉barite重晶石basic open-hearth furnace碱性平炉basic refractory [material] 碱性耐火材料basic slag碱性渣basicity of slag渣碱度basicoxide碱性氧化物bauxite铝土矿bell-less charging 无料钟装料belly炉腰bending roll弯曲辊bentonite 膨润土benzene苯billet caster小方坯连铸机binary-component phase diagram二元相图blast conditioning下部[鼓风]调节blast furnace campaign高炉寿命blast furnace process高炉炼铁[法]blast furnace高炉blast furnace鼓风炉blast humidity鼓风湿度blast pressure风压blast temperature风温blast volume鼓风量blast鼓风bleeder放散管bleeding valve炉顶放散阀bleeding 渗漏block flow sheet方框流程bloom caster大方坯连铸机blow end point吹炼终点blow off valve放散阀blow off停炉blow on开炉blowhole气孔Bohler electroslag tapping, BEST电渣浇注boiler steel锅炉钢borax硼砂boron nitride氮化硼bosh angle炉腹角bosh炉腹bottom boil炉底沸腾bottom casting下铸bottom-blown converter底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace, QBOF氧气底吹转炉bottom炉底boundary layer边界层bow-type continuous caster弧形连铸机breaking out拉漏briquette压块矿bubbling鼓泡bulging鼓肚bulk concentrate混合精矿bulk concentration体内浓度burden conditioning上部[炉料]调节burner blower助燃风机burner shut-off valve切断阀burner燃烧器bustle pipe热风围管by-pass valve旁通阀calcite方解石calcium diferrite铁酸半钙calcium ferrite铁酸钙25calcium silicon硅钙calorific value发热值calorimeter量热计capped steel压盖沸腾钢car casting车铸carbide slag电石渣carbon black 炭黑carbon block炭块carbon boil碳沸腾carbon brick炭砖carbon brush炭刷carbon electrode 炭电极carbon materials[含]碳[元]素材料carbon micrography炭相[学]carbon-oxygen equilibrium碳一氧平衡carburizing steel渗碳钢cast iron铸铁casting cycle浇注周期casting house出铁场耐磨性 abrasive气孔 abscess横坐标 abscissa容纳、收纳 accommodating空气喷射 air ejection气动电机 air motor自动踏步控制 AJC=automatic jumping control 定中心、对中 align排成直线、列队、对中 alignment交替、轮流 alternate电流量 amperage锚固、地脚 anchor退火的 annealed一年一次的 annual能应用的、适用的、适合的 applicable应用 application增多，重视 appreciate接近、进给 approach适合的、特有的 appropriate裙板 apron相变 arrest装配、组装、配件 assembly分配 assignment奥氏体 austenite奥氏体轧制 austenite rolling奥氏体的 austenitic辅助液压 auxiliary hydraulic轴向的 axial后退、退回 backlash平衡力 balance force球面丝杆 ball jack screw包装带分配器 banding dispenser打捆带 banding strap冷却段 bank轴承架 bearing bracker轴承箱 bearing cage轴承座 bearing chock轴承滑块，托瓦 bearing shoes口径、钻孔 bore支架、托架 bracket脆性 brittle青铜 bronze水桶，废品箱 bucket四轮小车 buggy衬板 bushing碰撞仪 butt gauge计算 calculation凸轮 cam曲线度 cambering amount辊型误差 cambering profile悬梁 cantilever有能力的 capable能力 capacity渗碳 carburized小车，砂轮架 carriage延伸辊道 carry over table连铸坯分段剪 CC shear中心线 centerline离心机 centrifuge房间 chamber轴承座 chock垫板 choke liner27C形沟 C-hook溜槽 chute圆周运动 circular motion过滤设备 clean-up device间隙 clearance废钢收集装置 cobble catcher带卷打捆机 coil banding machine带卷运输机 coil conveyor带卷检查线 coil inspection line带卷提升机 coil lifter托卷臂 coil loading arm带卷打号机 coil marking machine开卷机 coil opener带卷鞍座 coil saddle带卷鞍座 coil skid带卷站 coil station卸卷小车 coil stripper car带卷回转台 coil turner带卷称重装置 coil weighter带卷跨 coil yard卷取机进口侧导板 coiler entry side guide 卷取温度 coiling temperature收缩状态 collapsed校准仪，准直仪 collimator燃烧 combustion补偿 compensated复杂的 complicate压缩空气 compressed air计算机数据传输线 computer data line凹面 concave构想，认为 conceive概念 concept水泥，钢筋混凝土 concrete条件 condition联接 conjunction控制台 console统一，一致 consortium控制器 controller凸面 convex凸形 convex profile输送，运输 convey冷却水 cooling water冷却水管 cooling water header相互作用 correlation腐蚀性的 corrosive支架 cradle托辊 cradle roll标准，准则 criterion临界点 critical point十字接头式万向接头 cross pin type universal joint结晶 crystallization立方体的 cubic曲线 curve剪切力 cutting force剪切速度 cutting speed周期的 cyclic圆柱度 cylindricity缓冲，减振 dampen十年 decade缺陷 defect偏转辊 deflector roll变形 deformation变形抗力 deformation resistance不管，危害 despite超声波式涡流探伤仪 detector of ultrasonic or eddy current type消耗，磨损 deteriorate不利的，有害的 detrimental数字位置传感器 digital positioning sensor先导伺服阀 diredt servo valve散乱，分散 dispersion忽视 disregard明显的，不同的 distinct分配器 distributor龙门式 double column type地下卷取机 down coiler翻转装置 down ender下游的 downstream转鼓 drum转鼓更换钩 drum changing hook柔性，柔软的 ductile延展性，延伸率 ductility变钝，钝的 dull29动态的 dynamic动平衡 dynamic balance偏心套 eccentricity ring偏心轴 eccentricity shaft弹性材料 elastic material电液伺服控制 electro-hydraulic servo control 高度 elevation除去，消除 eliminated经验的 empiric能量 energy必要的，必不可少的 essential优于，擅长 excel专有的 exclusive偏差 excursion实现 execute伸展 expand分离（拆卸）装置 extractor面板，花盘 faceplate特点，特征 feature毛毡 felt铁素体 ferrite铁素体轧钢 ferrite rolling铁素体结构 ferritic填充辊道 fill-in table精轧机出口温度 finisher delivery temperature 精轧机进口温度 finisher entry temperature裂纹 fissure固定导板 fixed guide法兰 flange楔形 flared shape平面液晶显示器 flat-face CRT裂纹 flaw易弯曲的 flexible挠性推爪 flexible dog荧光的 fluorescent尾座 foot stock地脚螺栓 foundation bolt全扩展状态 fully expanded漏斗形 funnel级别，钢种 grade晶粒 grain干油 grease磨床 grinder磨，打磨 ground挡板 guard导卫 guide导辊 guide roller导板 guide-liner导向导板 guiding apron旋转 gyrating手轮 hand wheel钩子 hanger床头 head stock高位水箱系统 head tank system集水管 header喷水横梁 header piping保温罩 heat holding cover高速飞剪 high speed strip shear高速穿带装置 high speed strip threading device 绞接 hinge高速转动体 hi-rotor起重机 hoist压紧辊 hold down roll1780热轧生产常用专用英语词汇Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯31Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapor cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却Head water tank 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平33Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Electric room 电气室Motor 电机Main motor 主电机Load 载荷35。

热轧生产常用专用英语词汇2008-12-29 09:53Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapour cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却Head water tunk 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Saddle 鞍座Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度MPM: meter per minute 米/分钟Torque 扭矩Rated torque 额定扭矩Voltage 电压Process computer 过程计算机Program 程序，编程PLC： programmable logic controller 可编程控制器Encoder 编码器Information 信息Ghost rolling 模拟轧制Measuring instrument 测量仪表X-ray X射线Thickness gauge 测厚仪Width gauge 测宽仪HMD: hot material detector 热金属探测仪CMD: cold material detector 冷金属探测仪Light barrier 光栅Automatic model 自动模式Semi-auto model 半自动模式Manual model 手动模式Emergency 紧急，急停Joggle 点动HMI：human machine interface 人机界面AC frequency converter 交流变频器I/O： input/output 输入/输出端口Step control 卷取机助卷辊的“踏步”控制Hydraulic system 液压系统Grease 甘油Oil 油，稀油Oil station 油站SSC: Short stroke control 短行程控制AGC: automatic gauge control 自动压下控制AWC: automatic width control 自动宽度控制Pump 泵Screw pump 螺杆泵Filter 过滤器，滤网Cylinder 液压缸，圆柱体Valve stand 阀台Accumulator 蓄能器Leakage 泄漏Product 产品Grade 钢种Batch 一炉，一批Batch No. 炉批号Coil 钢卷Strip 带钢，薄带钢Sheet 钢板，薄钢板Plate 中厚板Physical performance 物理性能Mechanical performance 机械性能Strength 强度Elongation 延伸Flatness 平直度Plasticity 塑性Crown/chamber 凸度Hardness 硬度Microstructure 微观组织结构Austenite 奥氏体Ferrite 铁素体Pearlite 珠光体Deep drawn 深冲SPHC 普通级热轧钢板（卷）SPHD 深冲级热轧钢板（卷）SPCC 普通级冷轧钢板（卷）SPCD 深冲级冷轧钢板（卷High strength low-alloy steel 低合金高强度钢Silicon steel 硅钢，电工钢Galvanizing 镀锌Coating 涂镀，涂层Heat treatment 热处理Aging 时效处理Annealing 退火Quenching 淬火OtherAlarm 报警Anchoring bolt 地脚螺栓Yield 产量，成材率Ton 吨Annual 一年的Month 月Day 日Shift 班Safety 安全Radioactive hazard 放射性伤害Caution 注意，小心Layout 平面布置Document 文件Documentation 技术文本，技术文件报价书TOP: take-over point 交接点4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes 统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes 化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation 反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram 二元相图binary-component phase diagram 三元相图ternary-component phase diagram 液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution 相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion 菲克第一扩散定律Fick’s 2nd law of diffusion 扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction 化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance 蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,VAR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制 long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping铸铁cast iron熟铁wrought iron电解铁electrolytic iron白口铸铁white cast iron灰口铸铁grey cast iron麻口铸铁mottled cast iron变性铸铁modified cast iron孕育铸铁inoculated cast iron冷硬铸铁chilled cast iron球墨铸铁nodular cast iron蠕墨铸铁vermicular cast iron可锻铸铁malleable cast iron半可锻铸铁semi-malleable cast iron奥氏体铸铁austenitic cast iron贝氏体铸铁bainitic cast iron共晶白口铁eutectic white iron亚共晶白口铁hypoeutectic white iron过共晶白口铁hypereutectic white iron结构钢constructional steel软钢mild steel普通碳素钢plain carbon steel正火钢normalized steel热轧钢hot rolled steel高强度低合金钢high-strength low-alloy steel 微合金钢micro-alloy steel冷轧钢cold rolled steel深冲钢deep drawing steel双相钢dual phase steel渗碳钢carburizing steel渗氮钢nitriding steel调质钢quenched and tempered steel超高强度钢ultra-high strength steel不锈钢stainless steel奥氏体不锈钢austenitic stainless steel铁素体不锈钢ferritic stainless steel马氏体不锈钢martensitic stainless steel双相不锈钢duplex stainless steel马氏体时效钢maraging steel耐蚀钢corrosion-resisting steel耐热钢heat-resisting steel弹簧钢spring steel易切削钢free-machining steel耐磨钢abrasion-resistant steel工具钢tool steel高速钢high-speed steel冷作模具钢cold-work die steel热作模具钢hot-work die steel钢筋钢reinforced bar steel钢轨钢rail steel轮箍钢type steel管线钢pipe line steel锅炉钢boiler steel电工钢electrical steel∧-shaped segregation倒V形偏析∨-shaped segregation V形偏析1 mass% solution standard质量１％溶液标准(态) abrasion resistance耐磨损性abrasion-resistant steel耐磨钢absorption吸附absorption吸收accelerated melting by coal-oxygen burner氧煤助熔acid open-hearth furnace酸性平炉acid oxide酸性氧化物acid refractory [material] 酸性耐火材料acid slag酸性渣activation energy活化能activity coefficient活度系数activity活度addition reagent添加剂adiabatic process绝热过程adjustable mold调宽结晶器after blow后吹agglomeration团聚aim carbon目标碳air bottom-blown acid converter酸性空气底吹转炉air bottom-blown basic converter碱性空气底吹转炉air gap空气隙air mist spray cooling气水喷雾冷却akermanite镁黄长石Al2O3-SiC-C brick氧化铝-碳化硅-炭砖alumina carbon brick 铝炭砖alumina chrome brick铝铬砖alumina magnesia brick铝镁炭转alumina氧化铝aluminium bullet shooting, ABS 铝弹脱氧法aluminosillicate refractory硅酸铝质耐火材料aluminothermic process, thermit process铝热法amorphous carbon无定形碳amphoteric两性氧化物andalusite红柱石andradite钙铁榴石anion阴离子annual mine output矿山年产量anode阳极anorthite钙长石apparent activation energy表现活化能arc bias 偏弧argon-oxygen decarburization process, AOD氩氧脱碳法Arrhenius equation阿伦尼乌斯方程arrival at mine full capacity矿山达产Arved lance carbon injection process, ALCI顶枪喷煤粉炼钢法asbestos石棉ASEA-SKF process电弧加热电磁搅拌钢包精炼法austenitic cast iron奥氏体铸铁austenitic stainless steel奥氏体不锈钢back pour, back feeding补浇bainitic cast iron贝氏体铸铁baling of scrap废钢打包ball growth by assimilation生球长大同化机理ball growth by coalescence生球长大聚合机理ball growth by layering生球长大成层机理ball mill球磨机balling disc圆盘造球机balling drum圆筒造球机balling index for iron ore concentrates精矿成球指数banking for coke oven焦炉焖炉barite重晶石basic open-hearth furnace碱性平炉basic refractory [material] 碱性耐火材料basic slag碱性渣basicity of slag渣碱度basicoxide碱性氧化物bauxite铝土矿bell-less charging 无料钟装料belly炉腰bending roll弯曲辊bentonite 膨润土benzene苯billet caster小方坯连铸机binary-component phase diagram二元相图blast conditioning下部[鼓风]调节blast furnace campaign高炉寿命blast furnace process高炉炼铁[法]blast furnace高炉blast furnace鼓风炉blast humidity鼓风湿度blast pressure风压blast temperature风温blast volume鼓风量blast鼓风bleeder放散管bleeding valve炉顶放散阀bleeding 渗漏block flow sheet方框流程bloom caster大方坯连铸机blow end point吹炼终点blow off valve放散阀blow off停炉blow on开炉blowhole气孔Bohler electroslag tapping, BEST电渣浇注boiler steel锅炉钢borax硼砂boron nitride氮化硼bosh angle炉腹角bosh炉腹bottom boil炉底沸腾bottom casting下铸bottom-blown converter底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace, QBOF氧气底吹转炉bottom炉底boundary layer边界层bow-type continuous caster弧形连铸机breaking out拉漏briquette压块矿bubbling鼓泡bulging鼓肚bulk concentrate混合精矿bulk concentration体内浓度burden conditioning上部[炉料]调节burner blower助燃风机burner shut-off valve切断阀burner燃烧器bustle pipe热风围管by-pass valve旁通阀calcite方解石calcium diferrite铁酸半钙calcium ferrite铁酸钙calcium silicon硅钙calorific value发热值calorimeter量热计capped steel压盖沸腾钢car casting车铸carbide slag电石渣carbon black 炭黑carbon block炭块carbon boil碳沸腾carbon brick炭砖carbon brush炭刷carbon electrode 炭电极carbon materials[含]碳[元]素材料carbon micrography炭相[学]carbon-oxygen equilibrium碳一氧平衡carburizing steel渗碳钢cast iron铸铁casting cycle浇注周期casting house出铁场耐磨性 abrasive气孔 abscess横坐标 abscissa容纳、收纳 accommodating空气喷射 air ejection气动电机 air motor自动踏步控制 AJC=automatic jumping control 定中心、对中 align排成直线、列队、对中 alignment交替、轮流 alternate电流量 amperage锚固、地脚 anchor退火的 annealed一年一次的 annual能应用的、适用的、适合的 applicable应用 application增多，重视 appreciate接近、进给 approach适合的、特有的 appropriate裙板 apron相变 arrest装配、组装、配件 assembly分配 assignment奥氏体 austenite奥氏体轧制 austenite rolling奥氏体的 austenitic辅助液压 auxiliary hydraulic轴向的 axial后退、退回 backlash平衡力 balance force球面丝杆 ball jack screw包装带分配器 banding dispenser 打捆带 banding strap冷却段 bank轴承架 bearing bracker轴承箱 bearing cage轴承座 bearing chock轴承滑块，托瓦 bearing shoes 口径、钻孔 bore支架、托架 bracket脆性 brittle青铜 bronze水桶，废品箱 bucket四轮小车 buggy衬板 bushing碰撞仪 butt gauge计算 calculation凸轮 cam曲线度 cambering amount辊型误差 cambering profile悬梁 cantilever有能力的 capable能力 capacity渗碳 carburized小车，砂轮架 carriage延伸辊道 carry over table连铸坯分段剪 CC shear中心线 centerline离心机 centrifuge房间 chamber轴承座 chock垫板 choke linerC形沟 C-hook溜槽 chute圆周运动 circular motion过滤设备 clean-up device间隙 clearance废钢收集装置 cobble catcher带卷打捆机 coil banding machine带卷运输机 coil conveyor带卷检查线 coil inspection line带卷提升机 coil lifter托卷臂 coil loading arm带卷打号机 coil marking machine开卷机 coil opener带卷鞍座 coil saddle带卷鞍座 coil skid带卷站 coil station卸卷小车 coil stripper car带卷回转台 coil turner带卷称重装置 coil weighter带卷跨 coil yard卷取机进口侧导板 coiler entry side guide 卷取温度 coiling temperature收缩状态 collapsed校准仪，准直仪 collimator燃烧 combustion补偿 compensated复杂的 complicate压缩空气 compressed air计算机数据传输线 computer data line凹面 concave构想，认为 conceive概念 concept水泥，钢筋混凝土 concrete条件 condition联接 conjunction控制台 console统一，一致 consortium控制器 controller凸面 convex凸形 convex profile输送，运输 convey冷却水 cooling water冷却水管 cooling water header相互作用 correlation腐蚀性的 corrosive支架 cradle托辊 cradle roll标准，准则 criterion临界点 critical point十字接头式万向接头 cross pin type universal joint结晶 crystallization立方体的 cubic曲线 curve剪切力 cutting force剪切速度 cutting speed周期的 cyclic圆柱度 cylindricity缓冲，减振 dampen十年 decade缺陷 defect偏转辊 deflector roll变形 deformation变形抗力 deformation resistance不管，危害 despite超声波式涡流探伤仪 detector of ultrasonic or eddy current type消耗，磨损 deteriorate不利的，有害的 detrimental数字位置传感器 digital positioning sensor先导伺服阀 diredt servo valve散乱，分散 dispersion忽视 disregard明显的，不同的 distinct分配器 distributor龙门式 double column type地下卷取机 down coiler翻转装置 down ender下游的 downstream转鼓 drum转鼓更换钩 drum changing hook柔性，柔软的 ductile延展性，延伸率 ductility变钝，钝的 dull动态的 dynamic动平衡 dynamic balance偏心套 eccentricity ring偏心轴 eccentricity shaft弹性材料 elastic material电液伺服控制 electro-hydraulic servo control 高度 elevation除去，消除 eliminated经验的 empiric能量 energy必要的，必不可少的 essential优于，擅长 excel专有的 exclusive偏差 excursion实现 execute伸展 expand分离（拆卸）装置 extractor面板，花盘 faceplate特点，特征 feature毛毡 felt铁素体 ferrite铁素体轧钢 ferrite rolling铁素体结构 ferritic填充辊道 fill-in table精轧机出口温度 finisher delivery temperature 精轧机进口温度 finisher entry temperature裂纹 fissure固定导板 fixed guide法兰 flange楔形 flared shape平面液晶显示器 flat-face CRT裂纹 flaw易弯曲的 flexible挠性推爪 flexible dog荧光的 fluorescent尾座 foot stock地脚螺栓 foundation bolt框架 frame全扩展状态 fully expanded漏斗形 funnel级别，钢种 grade晶粒 grain干油 grease磨床 grinder磨，打磨 ground挡板 guard导卫 guide导辊 guide roller导板 guide-liner导向导板 guiding apron旋转 gyrating手轮 hand wheel钩子 hanger床头 head stock高位水箱系统 head tank system集水管 header喷水横梁 header piping保温罩 heat holding cover高速飞剪 high speed strip shear高速穿带装置 high speed strip threading device 绞接 hinge高速转动体 hi-rotor起重机 hoist压紧辊 hold down roll1780热轧生产常用专用英语词汇Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapor cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却Head water tank 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度。

钢铁生产常用专用英语词汇Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 熄灭Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapour cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 紧缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交流器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反应Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输入辊道Laminar cooling 层流冷却Head water tunk 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢阻拦装置Gear motor 齿轮马达Coupling 接手，衔接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 任务辊磨床Combinative/universal grinder 组合磨床Work roll 任务辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 任务辊轴承座Work roll bending system 任务辊弯辊系统Work roll shifting system 任务辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 任务辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 公允度Contour 外形轮廓Geometry 几何尺寸，几何外形Curve 曲线Sine curve 正玄曲线Active curve 实践曲线Rated curve 额外曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏向Error 误差，错误Offset 偏向量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给形式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 外表Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平零件Saddle 鞍座Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度MPM: meter per minute 米/分钟Torque 扭矩Rated torque 额外扭矩Voltage 电压Process computer 进程计算机Program 顺序，编程PLC：programmable logic controller 可编程控制器Encoder 编码器Information 信息Ghost rolling 模拟轧制Measuring instrument 测量仪表X-ray X射线Thickness gauge 测厚仪Width gauge 测宽仪HMD: hot material detector 热金属探测仪CMD: cold material detector 冷金属探测仪Light barrier 光栅Automatic model 自动形式Semi-auto model 半自动形式Manual model 手动形式Emergency 紧急，急停Joggle 点动HMI：human machine interface 人机界面AC frequency converter 交流变频器I/O：input/output 输入/输入端口Step control 卷取机助卷辊的〝踏步〞控制Hydraulic system 液压系统Grease 甘油Oil 油，稀油Oil station 油站SSC: Short stroke control 短行程控制AGC: automatic gauge control 自动压下控制AWC: automatic width control 自动宽度控制Pump 泵Screw pump 螺杆泵Filter 过滤器，滤网Cylinder 液压缸，圆柱体Valve stand 阀台Accumulator 蓄能器Leakage 走漏Product 产品Grade 钢种Batch 一炉，一批Batch No. 炉批号Coil 钢卷Strip 带钢，薄带钢Sheet 钢板，薄钢板Plate 中厚板Physical performance 物理功用Mechanical performance 机械功用Strength 强度Elongation 延伸Flatness 平直度Plasticity 塑性Crown/chamber 凸度Hardness 硬度Microstructure 微观组织结构Austenite 奥氏体Ferrite 铁素体Pearlite 珠光体Deep drawn 深冲SPHC 普通级热轧钢板〔卷〕SPHD 深冲级热轧钢板〔卷〕SPCC 普通级冷轧钢板〔卷〕SPCD 深冲级冷轧钢板〔卷High strength low-alloy steel 低合金高强度钢Silicon steel 硅钢，电工钢Galvanizing 镀锌Coating 涂镀，涂层Heat treatment 热处置Aging 时效处置Annealing 退火Quenching 淬火OtherAlarm 报警Anchoring bolt 地脚螺栓Yield 产量，成材率Ton 吨Annual 一年的Month 月Day 日Shift 班Safety 平安Radioactive hazard 放射性损伤Caution 留意，小心Layout 平面布置Document 文件Documentation 技术文本，技术文件报价书TOP: take-over point 交接点IC Initial conditions 初始条件PC Permanent conditions 固定条件MAN Manual run 人工运转AUTO Automatic run 自动运转HS High speed 高速LS Low speed 低速VLS Very low speed 匍匐FWD Forward 行进REV/BWD Reverse – backward 前进DS Delayed stop 延时停车NS Normal stop 正常停车FS Fast stop 快停ES Emergency stop 急停RM Roughing mill 粗轧机RCS Roll Change Side 换辊侧DS Drive side 传动侧。

1 炼焦炼焦coking高温炭化high temperature carbonization 塑性成焦机理plastic mechanism of coke formation 中间相成焦机理mesophase mechanism of coke formation 选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke 焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke 焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin 精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker 合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite 硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick 泡砂石quartzite sandstone 酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory 半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick 镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle 定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization 石墨纯净化处理purification treatment of graphite炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode 石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood 矮炉身电炉low-shaft electric furnace5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore 复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine 环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering 生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates 生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing 链算机-回转窑陪烧球团grate-kiln for pellet firing环式机陪烧球团circular gates for pellet firing 冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process 高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging 无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底 bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch 渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler 风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun 开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve 送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove 顶燃式热风炉top combustion stove 炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making 直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace 流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking 双联炼钢法duplex steelmaking process 连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period 精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation 还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat 出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials 添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygenfurnace,QBOF顶底复吹转炉top and bottom combined blown converter 喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE 顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI 蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice 增碳操作recarburization practice 单渣操作single-slag operation 双渣操作double-slag operation 渣乳化slag emulsion二次燃烧postcombustion 吹氧时间oxygen blow duration 吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector 废气控制系统off gas control system,OGCS 平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace 直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,VAR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC 等离子凝壳铸造plasma skull casting,PSC 能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制 long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization 鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,VAD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法 Dortmund Horder vacuum degassing process,DH 循环式真空脱气法 Ruhstahl-Hausen vacuum degassing process,RH真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argonbubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process 真空吹氧脱碳法vacuum oxygen decarburization process ,VOD 氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM 弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster[连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice 多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS 浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top钢锭缩头piped top表面缺陷surface defect内部缺陷internal defect缩孔shrinkage cavity中心缩孔center line shrinkage气孔blowhole表面气孔surface blowhole皮下气孔subskin blowhole针孔pinhole铸疤feather冷隔cold shut炼钢缺陷lamination发裂flake,hair crack纵裂longitudinal crack横裂transverse crack角部横向裂纹transverse corner crack角部纵向裂纹longitudinal corner crack收缩裂纹shrinkage crack热裂hot crack冷裂cold crack冷脆cold shortness热脆hot shortness夹渣slag inclusion皮下夹杂subsurface inclusion正偏析positive segregation负偏析negative segregation,inverse seregation V形偏析∨-shaped segregation倒V形偏析∧-shaped segregation中心偏析center segregation中心疏松center porosity鼓肚bulging脱方rhomboidity连铸-直接轧制continuous casting-direct rolling工艺CC-DR9 钢铁材料铸铁cast iron熟铁wrought iron电解铁electrolytic iron白口铸铁white cast iron灰口铸铁grey cast iron麻口铸铁mottled cast iron变性铸铁modified cast iron孕育铸铁inoculated cast iron冷硬铸铁chilled cast iron球墨铸铁nodular cast iron蠕墨铸铁vermicular cast iron可锻铸铁malleable cast iron 半可锻铸铁semi-malleable cast iron 奥氏体铸铁austenitic cast iron贝氏体铸铁bainitic cast iron共晶白口铁eutectic white iron亚共晶白口铁hypoeutectic white iron过共晶白口铁hypereutectic white iron结构钢constructional steel软钢mild steel普通碳素钢plain carbon steel正火钢normalized steel热轧钢hot rolled steel高强度低合金钢high-strength low-alloy steel 微合金钢micro-alloy steel冷轧钢cold rolled steel深冲钢deep drawing steel双相钢dual phase steel渗碳钢carburizing steel渗氮钢nitriding steel调质钢quenched and tempered steel超高强度钢ultra-high strength steel不锈钢stainless steel奥氏体不锈钢austenitic stainless steel铁素体不锈钢ferritic stainless steel马氏体不锈钢martensitic stainless steel 双相不锈钢duplex stainless steel马氏体时效钢maraging steel耐蚀钢corrosion-resisting steel耐热钢heat-resisting steel弹簧钢spring steel易切削钢free-machining steel耐磨钢abrasion-resistant steel工具钢tool steel高速钢high-speed steel冷作模具钢cold-work die steel热作模具钢hot-work die steel钢筋钢reinforced bar steel钢轨钢rail steel轮箍钢type steel管线钢pipe line steel锅炉钢boiler steel电工钢electrical steel10、冶金英语采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy 冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization ofmineralresources中国金属学会The Chinese Society for Metals 中国有色金属学会The Nonferrous Metals Society of China采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle 粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate 混合精矿bulk concentrate 最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing 粗碎primary crushing 中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer。

钢铁工业中英文词汇表iron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模 (美作:mold)tuyere, nozzle 风口ingot mould 锭模 (美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬 (美作:blowtorch) crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿 (美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型 (美作:molding)calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔材料科学 Material Science材料科学定义 Material Science Definition加工性能 Machinability强度 Strength抗腐蚀及耐用 Corrosion & resistance durability金属特性 Special metallic features抗敏感及环境保护 Allergic, re-cycling & environmental protection化学元素 Chemical element元素的原子序数 Atom of Elements原子及固体物质 Atom and solid material原子的组成、大小、体积和单位图表 The size, mass, charge of an atom, and is particles (Pronton,Nentron and Electron)原子的组织图 Atom Constitutes周期表 Periodic Table原子键结 Atom Bonding金属与合金 Metal and Alloy铁基合金 Ferrous Alloy铁及非铁金属 Ferrous & Non Ferrous Metal金属的特性 Features of Metal晶体结构 Crystal Pattern晶体结构，定向格子及单位晶格 Crystal structure, Space lattice & Unit cellX线结晶分析法 X – ray crystal analyics method金属材料的试验方法 The Method of Metal inspection不破坏检验 Non – destructive inspections渗透探伤法 Penetrate inspection磁粉探伤法 Magnetic particle inspection放射线探伤法 Radiographic inspection超声波探伤法 Ultrasonic inspection显微观察法 Microscopic inspection破坏的检验 Destructive Inspection冲击测试 Impact Test疲劳测试 Fatigue Test金属结晶格子 Metal space lattice格子常数 Lattice constant米勒指数 Mill's Index金相及相律 Metal Phase and Phase Rule固熔体 Solid solution置换型固熔体 Substitutional type solid solution插入型固熔体 Interstital solid solution金属间化物 Intermetallic compound金属变态 Transformation变态点 Transformation Point磁性变态 Magnetic Transformation同素变态 Allotropic Transformation合金平衡状态 Thermal Equilibrium相律 Phase Rule自由度 Degree of freedom临界温度 Critical temperture共晶 Eutectic包晶温度 Peritectic Temperature包晶反应 Peritectic Reaction包晶合金 Peritectic Alloy亚共晶体 Hypoeutetic Alloy过共晶体 Hyper-ectectic Alloy金属塑性 Plastic Deformation滑动面 Slip Plan畸变 Distortion硬化 Work Hardening退火 Annealing回复柔软 Crystal Recovery再结晶 Recrystallization金属材料的性能及试验 Properties & testing of metal化学性能 Chemical Properties物理性能 Physical Properties磁性 Magnetisum比电阻 Specific resistivity & specific resistance比重 Specific gravity & specific density比热 Specific Heat热膨胀系数 Coefficient of thermal expansion导热度 Heat conductivity机械性能 Mechanical properties屈服强度(降伏强度) (Yield strangth)弹性限度、阳氏弹性系数及屈服点 elastic limit, Yeung's module of elasticity to yield point 伸长度 Elongation断面缩率 Reduction of area钢铁的主要成份 The major element of steel钢铁用"碳"之含量来分类 Classification of Steel according to Carbon contents铁相 Steel Phases钢铁的名称 Name of steel纯铁体 Ferrite渗碳体 Cementitle奥氏体 Austenite珠光体及共释钢 Pearlite &Eutectoid 奥氏体碳钢 Austenite Carbon Steel 单相金属 Single Phase Metal共释变态 Eutectoid Transformation 珠光体 Pearlite亚铁释体 Hyppo-Eutectoid初释纯铁体 Pro-entectoid ferrite 过共释钢 Hype-eutectoid珠光体 Pearlite粗珠光体 Coarse pearlite中珠光体 Medium pearlite幼珠光体 Fine pearlite马氏体 mainite贝氏体 bainite物料科学Material Science物料科学定义Material Science Definition加工性能Machinability强度Strength抗腐蚀及耐用Corrosion & resistance durability金属特性Special metallic features抗敏感及环境保护Allergic, re-cycling & environmental protection化学元素Chemical element元素的原子序数Atom of Elements原子及固体物质Atom and solid material原子的组成、大小、体积和单位图表The size, mass, charge of an atom, and is particles (Pronton,Nentron and Electron) 原子的组织图Atom Constitutes周期表Periodic Table原子键结Atom Bonding金属与合金 Metal and Alloy铁及非铁金属Ferrous & Non Ferrous Metal金属的特性Features of Metal晶体结构 Crystal Pattern晶体结构，定向格子及单位晶格Crystal structure, Space lattice & Unit cellX 线结晶分析法X – ray crystal analyics method金属结晶格子 Metal space lattice格子常数 Lattice constant米勒指数 Mill's Index金相及相律 Metal Phase and Phase Rule固熔体 Solid solution置换型固熔体 Substitutional type solid solution插入型固熔体 Interstital solid solution金属间化物 Intermetallic compound金属变态Transformation变态点Transformation Point磁性变态Magnetic Transformation同素变态Allotropic Transformation合金平衡状态Thermal Equilibrium相律Phase Rule自由度Degree of freedom临界温度Critical temperture共晶Eutectic包晶温度 Peritectic Temperature包晶反应 Peritectic Reaction包晶合金 Peritectic Alloy亚共晶体 Hypoeutetic Alloy过共晶体 Hyper-ectectic Alloy金属的相融、相融温度、晶体反应及合金在共晶合金、固熔孻共晶合金及偏晶反应的比较Equilibrium Comparision金属塑性 Plastic Deformation滑动面 Slip Plan畸变 Distortion硬化 Work Hardening退火 Annealing回复柔软 Crystal Recovery再结晶 Recrystallization金属材料的性能及试验Properties & test ing of metal化学性能Chemical Properties物理性能Physical Properties颜色Colour磁性Magnetisum比电阻Specific resistivity & specific resistance比重Specific gravity & specific density比热Specific Heat热膨胀系数Coefficient of thermal expansion导热度Heat conductivity机械性能 Mechanical properties屈服强度(降伏强度) (Yield strangth)弹性限度、阳氏弹性系数及屈服点elastic limit, Yeung's module of elasticity to yield point伸长度Elongation断面缩率Reduction of area金属材料的试验方法The Method of Metal inspection不破坏检验Non – destructive inspections渗透探伤法Penetrate inspection磁粉探伤法Magnetic particle inspection放射线探伤法Radiographic inspection超声波探伤法Ultrasonic inspection显微观察法Microscopic inspection破坏的检验Destructive Inspection冲击测试Impact Test疲劳测试Fatigue Test潜变测试 Creep Test潜变强度Creeps Strength第壹潜变期Primary Creep第二潜变期Secondary Creep第三潜变期Tertiary Creep主要金属元素之物理性质Physical properties of major Metal Elements工业标准及规格–铁及非铁金属Industrial Standard – Ferrous & Non – ferrous Metal磁力 Magnetic简介 General软磁 Soft Magnetic硬磁 Hard Magnetic磁场 Magnetic Field磁性感应 Magnetic Induction透磁度 Magnetic Permeability磁化率 Magnetic Susceptibility (Xm)磁力(Magnetic Force)及磁场(Magnetic Field)是因物料里的电子(Electron)活动而产生抗磁体、顺磁体、铁磁体、反铁磁体及亚铁磁体Diamagnetism, Paramagnetic, Ferromagnetism,Antiferromagnetism & Ferrimagnetism抗磁体 Diamagnetism磁偶极子 Dipole负磁力效应 Negative effect顺磁体 Paramagnetic正磁化率 Positive magnetic susceptibility铁磁体 Ferromagnetism转变元素 Transition element交换能量 Positive energy exchange外价电子 Outer valence electrons化学结合 Chemical bond自发上磁 Spontaneous magnetization磁畴 Magnetic domain相反旋转 Opposite span比较抗磁体、顺磁体及铁磁体Comparison of Diamagnetism, Paramagnetic & Ferromagnetism 反铁磁体 Antiferromagnetism亚铁磁体 Ferrimagnetism磁矩 magnetic moment净磁矩 Net magnetic moment钢铁的主要成份The major element of steel钢铁用"碳"之含量来分类Classification of Steel according to Carbon contents铁相Steel Phases钢铁的名称Name of steel纯铁体Ferrite渗碳体Cementitle奥氏体 Austenite珠光体及共释钢Pearlite &Eutectoid奥氏体碳钢Austenite Carbon Steel单相金属Single Phase Metal共释变态Eutectoid Transformation珠光体 Pearlite亚铁释体Hyppo-Eutectoid初释纯铁体 Pro-entectoid ferrite过共释钢 Hype-eutectoid珠光体Pearlite粗珠光体 Coarse pearlite中珠光体 Medium pearlite幼珠光体 Fine pearlite磁性变态点 Magnetic Transformation钢铁的制造Manufacturing of Steel连续铸造法 Continuous casting process电炉 Electric furnace均热炉 Soaking pit全静钢 Killed steel半静钢 Semi-killed steel沸腾钢(未净钢) Rimmed steel钢铁生产流程 Steel Production Flow Chart钢材的熔铸、锻造、挤压及延轧The Casting, Fogging, Extrusion, Rolling & Steel熔铸 Casting锻造 Fogging挤压 Extrusion延轧 Rolling冲剪 Drawing & stamping特殊钢 Special Steel简介General特殊钢以原素分类Classification of Special Steel according to Element特殊钢以用途来分类Classification of Special Steel according to End Usage易车(快削)不锈钢Free Cutting Stainless Steel含铅易车钢Leaded Free Cutting Steel含硫易车钢Sulphuric Free Cutting Steel硬化性能Hardenability钢的脆性Brittleness of Steel低温脆性 Cold brittleness回火脆性 Temper brittleness日工标准下的特殊钢材Specail Steel according to JIS Standard铬钢–日工标准 JIS G4104Chrome steel to JIS G4104铬钼钢钢材–日工标准 G4105 62Chrome Molybdenum steel to JIS G4105镍铬–日工标准 G4102 63Chrome Nickel steel to JIS G4102镍铬钼钢–日工标准 G4103 64Nickel, Chrome & Molybdenum Steel to JIS G4103高锰钢铸–日工标准High manganese steel to JIS standard片及板材Chapter Four-Strip, Steel & Plate冷辘低碳钢片(双单光片)(日工标准 JIS G3141) 73 - 95Cold Rolled (Low carbon) Steel Strip (to JIS G 3141)简介General美材试标准的冷辘低碳钢片Cold Rolled Steel Strip American Standard – American Society for testing and materials (ASTM)日工标准JIS G3141 冷辘低碳钢片(双单光片)的编号浅释Decoding of cold rolled(Low carbon)steel strip JIS G3141材料的加工性能 Drawing abillity硬度 Hardness表面处理 Surface finish冷辘钢捆片及张片制作流程图表Production flow chart cold rolled steel coil sheet冷辘钢捆片及张片的电镀和印刷方法Cold rolled steel coil & sheet electro-plating & painting method冷辘(低碳)钢片的分类用、途、工业标准、品质、加热状态及硬度表End usages, industrial standard, quality, condition and hardness of cold rolled steel strip硬度及拉力 Hardness & Tensile strength test拉伸测试(顺纹测试)Elongation test杯突测试(厚度: 0.4 公厘至1.6 公厘，准确至0.1 公厘 3 个试片平均数)Erichsen test (Thickness: 0.4mm to 1.6mm, figure round up to 0.1mm)曲面(假曲率)Camber厚度及阔度公差 Tolerance on Thickness & Width平坦度(阔度大于500 公厘，标准回火)Flatness (width>500mm, temper: standard)弯度 Camber冷辘钢片储存与处理提示General advice on handling & storage of cold rolled steel coil & sheet防止生锈Rust Protection生锈速度表Speed of rusting焊接 Welding气焊 Gas Welding埋弧焊 Submerged-arc Welding电阻焊 Resistance Welding冷辘钢片(拉力: 30-32 公斤/平方米)在没有表面处理状态下的焊接状况Spot welding conditions for bared (free from paint, oxides etc) Cold rolled mild steelsheets(T/S:30-32 Kgf/ μ m2)时间效应(老化)及拉伸应变Aging & Stretcher Strains日工标准(JIS G3141)冷辘钢片化学成份Chemical composition – cold rolled steel sheet to JIS G3141冷辘钢片的"理论重量"计算方程式Cold Rolled Steel Sheet – Theoretical mass日工标准(JIS G3141)冷辘钢片重量列表Mass of Cold-Rolled Steel Sheet to JIS G3141冷辘钢片订货需知Ordering of cold rolled steel strip/sheet其它日工标准冷轧钢片(用途及编号)JIS standard & application of other cold Rolled Special Steel电镀锌钢片或电解钢片Electro-galvanized Steel Sheet/Electrolytic Zinc Coated Steel Sheet简介General电解/电镀锌大大增强钢片的防锈能力Galvanic Action improving Weather & Corrosion Resistance of the Base Steel Sheet上漆能力 Paint Adhesion电镀锌钢片的焊接Welding of Electro-galvanized steel sheet点焊Spot welding滚焊Seam welding电镀锌(电解)钢片Electro-galvanized Steel Sheet生产流程Production Flow Chart常用的镀锌钢片(电解片)的基层金属、用途、日工标准、美材标准及一般厚度Base metal, application, JIS & ASTM standard, and Normal thickness of galvanized steel sheet锌镀层质量 Zinc Coating Mass表面处理 Surface Treatment冷轧钢片 Cold-Rolled Steel Sheet/Strip热轧钢片 Hot-Rolled Sheet/Strip电解冷轧钢片厚度公差Thickness Tolerance of Electrolytic Cold-rolled sheet热轧钢片厚度公差Thickness Tolerance of Hot-rolled sheet冷轧或热轧钢片阔度公差Width Tolerance of Cold or Hot-rolled sheet长度公差 Length Tolerance理论质量 Theoretical Mass锌镀层质量(两个相同锌镀层厚度)Mass Calculation of coating (For equal coating)/MM锌镀层质量(两个不同锌镀层厚度)Mass Calculation of coating (For differential coating)/MM镀锡薄铁片(白铁皮/马口铁) (日工标准 JIS G3303)简介General镀锡薄铁片的构造Construction of Electrolytic Tinplate镀锡薄钢片(白铁皮/马日铁)制造过程Production Process of Electrolytic Tinplate锡层质量Mass of Tin Coating (JIS G3303-1987)两面均等锡层Both Side Equally Coated Mass两面不均等锡层Both Side Different Thickness Coated Mass级别、电镀方法、镀层质量及常用称号Grade, Plating type, Designation of Coating Mass & Common Coating Mass 镀层质量标记Markings & Designations of Differential Coatings硬度 Hardness单相轧压镀锡薄铁片(白铁皮/马口铁)Single-Reduced Tinplate双相辗压镀锡薄钢片(马口铁/白铁皮)Dual-Reduction Tinplate钢的种类 Type of Steel表面处理 Surface Finish常用尺寸 Commonly Used Size电器用硅 [硅] 钢片 Electrical Steel Sheet简介 General软磁材料 Soft Magnetic Material滞后回线 Narrow Hystersis矫顽磁力 Coercive Force硬磁材料 Hard Magnetic Material最大能量积 Maximum Energy Product硅含量对电器用的低碳钢片的最大好处The Advantage of Using Silicon low Carbon Steel晶粒取向(Grain-Oriented)及非晶粒取向(Non-Oriented)Grain Oriented & Non-Oriented电器用硅 [硅] 钢片的最终用途及规格End Usage and Designations of Electrical Steel Strip电器用的硅 [硅] 钢片之分类Classification of Silicon Steel Sheet for Electrical Use电器用钢片的绝缘涂层Performance of Surface Insulation of Electrical Steel Sheets晶粒取向电器用硅钢片主要工业标准International Standard – Grain-Oriented Electrical Steel Silicon Steel Sheet for Electrical Use晶粒取向电器用硅钢片 Grain-Oriented Electrical Steel晶粒取向，定取向芯钢片及高硼定取向芯钢片之磁力性能及夹层系数(日工标准及美材标准) Magnetic Properties and Lamination Factor of SI-ORIENT-CORE& SI-ORIENT-CORE-HI BElectrical Steel Strip (JIS and AISI Standard)。

1. indication 缺陷2. test specimen 试样3. bar 棒材4. stock 原料5. billet 方钢，钢方坯6. bloom 钢坯,钢锭7. section 型材8. steel ingot 钢锭9. blank 坯料，半成品10. cast steel 铸钢11. nodular cast iron 球墨铸铁12. ductile cast iron 球墨铸铁13. bronze 青铜14. brass 黄铜15. copper 合金16. stainless steel不锈钢17. decarburization 脱碳18. scale 氧化皮19. anneal 退火20. process anneal 进行退火21. quenching 淬火22. normalizing 正火23. Charpy impact text 夏比冲击试验24. fatigue 疲劳25. tensile testing 拉伸试验26. solution 固溶处理27. aging 时效处理28. Vickers hardness维氏硬度29. Rockwell hardness 洛氏硬度30. Brinell hardness 布氏硬度31. hardness tester硬度计32. descale 除污，除氧化皮等33. ferrite 铁素体34. austenite 奥氏体35. martensite马氏体36. cementite 渗碳体37. iron carbide 渗碳体38. solid solution 固溶体39. sorbite 索氏体40. bainite 贝氏体41. pearlite 珠光体42. nodular fine pearlite/ troostite屈氏体43. black oxide coating 发黑44. grain 晶粒45. chromium 铬46. cadmium 镉47. tungsten 钨48. molybdenum 钼49. manganese 锰50. vanadium 钒51. molybdenum 钼52. silicon 硅53. sulfer/sulphur 硫54. phosphor/ phosphorus 磷55. nitrided 氮化的56. case hardening 表面硬化，表面淬硬57. air cooling 空冷58. furnace cooling 炉冷59. oil cooling 油冷60. electrocladding /plating 电镀61. brittleness 脆性62. strength 强度63. rigidity 刚性,刚度64. creep 蠕变65. deflection 挠度66. elongation 延伸率67. yield strength 屈服强度68. elastoplasticity 弹塑性69. metallographic structure 金相组织70. metallographic test 金相试验71. carbon content 含碳量72. induction hardening 感应淬火73. impedance matching 感应淬火74. hardening and tempering 调质75. crack 裂纹76. shrinkage 缩孔，疏松77. forging 锻（件）78. casting 铸（件）79. rolling 轧（件）80. drawing 拉（件）81. shot blasting 喷丸（处理）82. grit blasting 喷钢砂（处理）83. sand blasting 喷砂（处理）84. carburizing 渗碳85. nitriding 渗氮86. ageing/aging 时效87. grain size 晶粒度88. pore 气孔89. sonim 夹砂90. cinder inclusion 夹渣91. lattice晶格92. abrasion/abrasive/rub/wear/wearing resistance (property) 耐磨性93. spectrum analysis光谱分析94. heat/thermal treatment 热处理95. inclusion 夹杂物96. seGREgation 偏析97. picking 酸洗，酸浸98. residual stress 残余应力99. remaining stress 残余应力100. relaxation of residual stress 消除残余应力101. stress relief 应力释放A R steel 高温度锰钢abnormal steel 反常钢; 非正常钢aluminium-steel cable 钢铝电缆aluminized steel 涂铝钢aluminum nickel steel 铝镍钢anchored steel trestle 锚固式钢栈桥angle steel ruler 钢角尺anisotropic steel 各向异性钢片anisotropy silicon steel 各向异性硅钢片annealed sheet steel 退火薄钢板annealed steel 退火钢; 韧钢anti-creeping angle steel 防爬角铁anticorrosive aluminium-coated steel wire 防蚀镀铝钢丝arc-furnace steel 电炉钢arc-welded steel pipe 电弧焊接钢管area of steel 钢筋断面面积; 钢筋截面面积area of structural steel 型钢截面积Armco aluminized steel 阿姆柯渗铝钢armco aluminized steel 表面浸镀铝钢Armco stabilized steel 阿母柯稳定化钢Armco steel 阿姆柯软钢armco steel 不硬化钢austenilic Ni-Cr stainless steel 奥氏体镍铬不锈钢austenitic alloy steel 奥氏体合金钢austenitic chromium-nickel steel 奥氏体铬-镍钢austenitic clad steel 奥氏体复合钢austenitic heat-resistance steel 奥氏体耐热钢austenitic manganese steel 奥氏体锰钢; 哈德菲尔德锰钢austenitic stainless steel 奥氏体不锈钢austenitic steel 奥氏体钢automatic steel 易切削钢automatic(al) steel 易切削钢axle shaft steel 车轴钢axle steel 车轴钢钢铁业的英语词汇1Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Case-Hardened Steel 表面渗碳硬化钢; 渗碳钢Bolts & Nuts For Steel Slotted 角钢螺丝Cast Alloy Steel Piston 合金铸钢活塞Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 铸造不锈钢Cast Steel 铸钢件Cast Steel Plate 铸钢板Cast(Carbon) Steel 铸钢Cast-In Steel Bush 铸入钢套Casement Section Steel 窗框钢Cast-Steel 铸钢Cast-Steel Crossing 铸钢辙叉Cast-Steel Pipe 铸钢管Cast-Steel Separator 铸钢隔板; 铸钢横梁Cast-Steel Shot 钢砂Cast-Steel Yoke 铸钢轭Cellular Steel Floor 格型钢楼板Cement-And-Grouted Steel Bolt 钢筋砂浆锚杆Cemented Steel 表面硬化钢Cemented Templet Steel 渗碳样板钢Centra Steel 球状石墨铸钢Centrifugal Steel 离心铸钢Centrifuge(D) Steel 离心铸造钢Channel Steel 槽钢Channel-Section Steel 槽形钢Channeled-Steel Wheel Rim 槽钢制轮辋Checkered Steel Plate 花纹钢板Chemical Capped Steel 化学封顶钢Chilled Cast Steel 冷硬铸钢Chilled Hardened Steel 淬火钢Chilled Steel 淬火钢; 淬硬钢Chisel Steel 凿钢; 凿子钢Chrome Hardened Steel 铬硬化钢Chrome Steel 铬钢Chrome-Carbon Steel 铬碳钢Chrome-Manganese Nitrogen Steel 铬锰氮钢Chrome-Manganese-Silicon Alloy Steel 铬锰硅合金钢Chrome-Molybdenum Steel 铬钼钢Chrome-Nickel Steel 铬镍钢Chrome-Plated Steel Nozzle 镀铬钢喷管Chrome-Silicon Steel 铬硅钢Chrome-Tungsten Steel 铬钨钢Chrome-Vanadium Steel 铬钒钢Chromemanganese Steel 铬锰钢Chromium Nickel Steel 高强度耐蚀铬镍钢Chromium Stainless Steel 铬不锈钢Chromium Steel 铬钢Chromium-Molybdenum Steel 铬钼钢Chromium-Nickel Steel 铬镍钢Chromium-Plated Mild Steel Animal Chain 镀铬软钢动物链条Chromium-Tungstenvanadium Steel 铬钨钒钢Chromiummanganese Steel 铬锰钢Chromiumnickel Austenite Stainless Steel 铬镍奥氏体不锈钢Chromiumplated Thin-Walled Steel Cylinder Liner 钢质薄壁镀铬汽缸衬套Chromized Steel 渗铬钢Circular Steel Support 环形金属支架Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel 包覆钢Cladding Steel Sheet 复合钢板Clean Steel 纯净钢; 洁净钢Closed Die Steel 闭锻模钢Coarse-Grained Steel 粗晶粒钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧钢Cold-Rolled Carbon Spring Steel 冷轧弹簧碳钢Cold-Rolled Carbon Steel 冷轴碳钢Cold-Rolled Steel Strip 冷轧带钢Cold-Shaping Steel 冷变形钢Cold-Short Steel 冷脆钢Cold-Steel 利器Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Coldshort Steel 冷脆钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Column With Steel Hooping 螺旋箍筋柱Combined Steel And Concrete Column 钢骨混凝土柱Comminuted Steel Shot 钢粉Common Straight Carbon Steel 普通碳素钢Complex Alloy Steel 多元合金钢; 合金钢碳素结构钢 Carbon Construction Steel碳素工具钢 Carbon Tool Steel合金结构钢 Alloy Construction Steel合金工具钢 Alloy Tool Steel高速工具钢 High Speed Tool Steel弹簧钢 Spring Steel不锈耐热钢 Stainless & Heat Resisting Steel轴承钢 Bearing Steel工字钢 Ibeam普通圆钢 Round Steel槽钢 Channel扁钢Flat Steel Bar等边角钢 Equal Angle Steel不等边角钢 Unequal Angle Steelh型钢 Hbeam钢坯 Billet,Bloom钢筋混凝土用变形钢筋 High Strength Deformed Steel Bar 窗框钢 Window Sash中厚钢板 Steel Plate热轧钢板（卷） Hot Rolled Steel Coil冷轧钢板（卷） Cold Rolled Steel Sheel or Coil镀锌钢板（卷） Galvanized Steel Coil钢带 Steel Strip线材 Wire Rod Coil无缝钢管 Seamless Steel Pipe锅炉管 Boiler Tube石油套管 Pipe For Oil Field高压管 Pressure Pipe高压气瓶用管 Tube for High-Pressure Vessel地质钻探用管 Seamless Steel Pipe For Geological Drill In 镀锌焊管 Galvanized Welded Pipe石油钻探杆 Drill Pipe For Oil Field铸铁管 Cast Iron Pipe重轨 Heavy Rail轻轨 Light Rail炼钢生铁 Basic Pig Iron铸造生铁 foundry Pig Iron普通圆钢钉 Round Nails for General Uses镀锌底碳钢丝 Galvanized Low Carbon Steel Wire.钢丝绳 Steel Wire Rope钢绞线 Stranded Wire预应力混凝土钢丝 Steel Wire For Prestressed Concrete 窗纱 Window Screen车轮 Wheel Tyre轮筛 Wheel Circleiron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模(美作:mold) tuyere, nozzle 风口ingot mould 锭模(美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬(美作:blowtorch)crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿(美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型(美作:molding) calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔钢铁业的英语词汇2Abnormal Steel 反常钢; 非正常钢Aluminum-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Anchored Steel Trestle 锚固式钢栈桥Angle Steel Ruler 钢角尺Anisotropic Steel 各向异性钢片Anisotropy Silicon Steel 各向异性硅钢片Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Anti-Creeping Angle Steel 防爬角铁Anticorrosive Aluminum-Coated Steel Wire 防蚀镀铝钢丝1. Arc-Furnace Steel 电炉钢Arc-Welded Steel Pipe 电弧焊接钢管Area Of Steel 钢筋断面面积; 钢筋截面面积Area Of Structural Steel 型钢截面积Armco Aluminized Steel 阿姆柯渗铝钢Armco Aluminized Steel 表面浸镀铝钢Armco Stabilized Steel 阿母柯稳定化钢Armco Steel 阿姆柯软钢Armco Steel 不硬化钢Austenitic Ni-Cr Stainless Steel 奥氏体镍铬不锈钢Austenitic Alloy Steel 奥氏体合金钢Austenitic Chromium-Nickel Steel 奥氏体铬-镍钢Austenitic Clad Steel 奥氏体复合钢Austenitic Heat-Resistance Steel 奥氏体耐热钢Austenitic Manganese Steel 奥氏体锰钢; 哈德菲尔德锰钢Austenitic Stainless Steel 奥氏体不锈钢Austenitic Steel 奥氏体钢Automatic Steel 易切削钢Automatic(Al) Steel 易切削钢Axle Steel 车轴钢Bain tic Steel 贝氏体钢Balanced Steel 半镇静钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Bamboo Steel 竹节钢筋Band Steel 带钢Banding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Basic Bessemer Steel 碱性贝氏转炉钢Basic Bessemer Steel 碱性转炉钢Basic Bessemer Steel Converter 碱性转炉钢转炉Basic Converter Steel 碱性转炉钢Basic Electric Furnace Steel 碱性电炉钢Basic Open Hearth Steel 碱性平炉钢Battened Steel Column 双肢钢Beam Steel Plate 大梁钢板Beam With Compression Steel 双筋梁Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Bent Steel 挠曲钢筋Bessemer Low Carbon Steel 酸性转炉低碳钢Bessemer Mild Steel 贝色麦钢Bessemer Steel 贝色麦钢; 酸性钢Best Plough Steel Wire 铅淬火高强度钢丝Billet Steel 坯段钢; 钢坯; 短条钢Binary Steel 二元合金钢Black Mild Steel Carriage Bolt And Nut 黑铁马车螺丝闩Black Mild Steel Fish Bolt And Nut 黑铁鱼尾螺丝闩Black Mild Steel Flat Head Rivet 黑铁扁头铆钉Black Mild Steel Flat Head Tin men Rivet 黑铁号头铆钉Black Mild Steel Hexagonal Nut 黑铁六角螺丝帽Black Mild Steel Pan Head Rivet 黑铁锥头铆钉Black Mild Steel Round Head Rivet 黑铁圆头铆钉Black Mild Steel Square Nut 黑铁四方螺丝帽Black Steel Pipe 黑钢板Black Steel Sheet 黑钢皮Black Tin Steel 黑钢板Blister Steel 泡钢; 泡面钢Abnormal Structure Steel 反常组织钢Abrasion-Resistant Steel 耐磨钢Blue Steel 蓝钢Boiler Steel 锅炉钢; 锅炉钢板Boiler Steel Plate 锅炉钢板Boiling Steel 沸腾钢Bolting Steel 螺栓钢Blue Planished Steel 发蓝薄钢板Bloom Steel 初轧钢; 钢坯Boron Steel 硼钢Brass Fitting Of Steel Window 钢窗铜配件Brass-Plated Mild Steel Round Bead Wood Screw 镀黄铜圆头软钢木螺丝Brass-Plated Mild Steel Round Head Machine Screw 镀黄铜圆头软钢机器螺丝Brass-Plated Steel Wire 镀黄铜钢丝Brearley Steel 布里阿雷不锈钢; 布氏高铬钢Bridge Steel 桥梁钢Bright And Black Mild Steel Flat Head Tinmen Rivet 号头铆钉Bright Mild Steel Cotter Pin 光亮软钢开尾销Bright Mild Steel Countersunk Head Wood Screw 光亮软钢平头木螺丝Bright Mild Steel Hexagonal Nut 光亮软钢六角螺丝帽Bright Mild Steel Hexagonal Nuts 六角光螺帽; 六角螺丝帽Bright Mild Steel Hexagonal Pressed Nut 光亮软钢六角冲压螺丝帽Bright Mild Steel Round Head Wood Screw 光亮软钢圆头木螺丝Bright-Drawn Free Cutting Steel 光拉自由切削钢Bright-Drawn Steel 光亮拉拔钢材Bright-Finished Steel 光亮精整钢Bristol Steel Belt Lacing 布瑞斯涛钢带接头Bronze Steel 镀青铜钢Building Of Steel Frame Construction 钢框架房屋Bulb Steel 球扁钢Bulb-Rail Steel 球头丁字钢Burned Steel 过烧钢Calorized Steel 涂铝钢; 渗化钢Calorizing Steel 铝化钢Capped Steel 加盖钢; 半镇静钢Carbon And Low-Alloy Steel Vessels 碳钢及低合金钢容器Carbon Content Of Steel 钢含碳量Carbon Molybdenum Steel 钼碳钢Carbon Steel 碳钢; 碳素钢Carbon Steel Covered Electrode 碳钢焊条Carbon Steel Plate2. 中文名英文名品质描述6063 6063 Extrusion-pntd 镀漆6061 6061 Extrusion-pntd 镀漆生铝件 Tense 含铁〈2%生杂铝 Mixed Cast 含铁〈2%旧铝片 Old Sheet-Taint/Tabor 干净新铝片 Tough-Taboo 干净切碎铝 Shredded Aluminum 干净汽车切片铝 Shredded Auto Aluminum 含铝70%带铁铝 Irony Aluminum 需标明含量356轮毂铝 356 Auto Wheels 干净铝水箱 Aluminum Radiator 干净带皮铝线 Acsr/Ins 需标明含量铜铝水箱 Al/Cu Radiator 干净易拉罐 UBC-Baled/Densified 干净铝变压器 Aluminum Transformer铝壳马达 Aluminum Case Motor1#光亮铜线 #1 Bare Bright 干净1#铜 #1 Candy 含铜98%2#铜 #2 Birch/Cliff 含铜94-96%1#火烧线 #1 Burnt Wire 含铜〉97%1#铜米 #1 Cu-chop1#铜线缆 #1 Insulated Wire 含铜72%2#铜线缆 #2 Insulated Wire 含铜50-55%1#2#混合铜线缆 #1#2 Mixed Wire 含铜65%黄杂铜 Yellow Brass-Honey 干净干净铜水箱 Ocean Auto Radiator 干净(牛粪)切碎电机 Shredded Pickings 含铜18-20%混合电机 Electric Motors 含铜8-12%304炉料 304 Sabot 18-8304可利用料 304 Reusable 板或杆316可利用料 316 Reusable 板或杆3. 1、烧结sintering粉末或压坯在低于主要组分熔点的温度下的热处理，目的在于通过颗粒间的冶金结合以提高其强度。

钢铁生产常用专用英语词汇热轧生产常用专用英语词汇Heating area:加热区Furnace 加热炉Gas 煤气Mixed gas 混合煤气Nitrogen 氮气Oxygen 氧气Resident oxygen 炉内残氧Pressure 压力Volume 体积、流量Valve 阀门Slab 板坯Slab yard 板坯库Continuous cast slab 连铸板坯Width 宽度Thickness 厚度Length 长度Weight 重量Bend 弯曲Combust 燃烧Temperature 温度Centigrade degree 摄氏度Pyrometer 高温计Thermocouples 热电偶Fixed beam 固定梁Walking beam 步进梁Forward 向前Backward 向后Discard 剔除Discard table 剔除辊道Charge 装炉Discharge 出炉Preheating zone 预热区Heating zone 加热区Soaking zone 均热区Vaporizing cooling/ vapour cooling 气化冷却Soft water 软水Scale 氧化铁皮Ventilate 通风Chimney 烟囱Exhaust 废气Stack 烟道Roller table 辊道Baffle 挡板Charge machine 装钢机Discharge machine 出钢机Compressed air 压缩空气Burner 烧嘴Combustion air fan 助燃风机Recuperative heat exchanger回热式热交换器Refractory brick 耐火砖Mathematic model 数学模型Feed-forward 前馈Feedback 后馈/反馈Furnace pressure 炉压Temperature profile 温度曲线Hot rolling shop：热轧车间Mill 轧机4-high finishing mill 四辊精轧机Rough mill 粗轧Screw down 压下Screw up 抬升辊缝Edger 立辊轧机，轧边机High-pressure descaling system 高压水除鳞系统Nozzle 喷嘴Heat cover 保温罩Shear 剪机Hydraulic loop 液压活套Looper 活套辊Side guide 侧导卫Interstand cooling 机架间冷却Run-out table 精轧输出辊道Laminar cooling 层流冷却Head water tunk 高位水箱Side stripper 侧喷头Pinch roll 夹送辊Down Coiler 卷取机Mandrel 卷取机芯轴Wrapper roller 助卷辊Coil stripper car 卸卷小车Strip catcher 卷取区域带钢拦截装置Gear motor 齿轮马达Coupling 接手，连接器Spindle 接轴Universal Spindle 万向接轴Shaft 轴Roll changing device 换辊装置Crane 行车Bite 咬入Cascade speed adjustment 节联调速Cobble 堆钢事故，中间事故坯料Tension 张力Tension control 张力控制Loop height 活套量/活套高度Speed up 升速Lock cylinder 锁紧缸Balance cylinder 平衡缸Lift 提升Shift 横移Leveling 校平，调平Zero 校零Alignment 对中Industrial water 循环水Water volume 水量Water pressure 水压Cooling rate 冷却速度Speed cone 速度锥Maintenance 检修，维护Pneumatic system 气动系统Roll shop 轧辊间Roll 轧辊Grinder 磨床Work roll grinder 工作辊磨床Combinative/universal grinder 组合磨床Work roll 工作辊Back-up roll 支撑辊Barrel 辊身Roll neck 辊颈Roll cooling 轧辊冷却Work roll chock 工作辊轴承座Work roll bending system 工作辊弯辊系统Work roll shifting system 工作辊窜辊系统Back-up roll chock 支撑辊轴承座Bearing 轴承Work roll bearing 工作辊轴承Oil film bearing/morgoil bearing 油膜轴承Headstock 头架Tailstock 尾架Grinding carriage 磨头滑架Wheel 砂轮Dressing diamond 修整金刚石Measure 测量Size 尺寸Diameter 直径Ovality 不圆度Roundness 圆度Eccentricity 偏心度Contour 外形轮廓Geometry 几何尺寸，几何形状Curve 曲线Sine curve 正玄曲线Active curve 实际曲线Rated curve 额定曲线/设定的曲线Position 位置Axis 轴，数轴Horizontal 水平的Vertical 垂直的Calibration 校准，刻度Compensation 补偿Correction 纠正Control panel 控制面板，操作控制台Deviation 偏差Error 误差，错误Offset 偏差量Definition 定义Reverse 反转Swivel 回转，转动Distance 距离Range 范围Chamfer 凸度Centerline 中心线Infeed mode 进给模式Limit 限制，极限Limit switch 限位开关Scan 扫描Coolant 冷却剂Surface 表面Plunge grinding 掏沟磨削Caliper 测量卡规Optimize 优化Load roll 装辊Unload roll 卸辊Calibrate caliper 校准测量卡规Finishing area 精整区域Coil marking machine 钢卷标号机Coil strapping machine 钢卷打捆机Coil weighing device 钢卷称重装置Sampling shear 取样剪Transfer chain 链条运输机Walking beam transfer 步进梁运输机Coil yard 钢卷库Skin pass 平整机Saddle 鞍座Electric room 电气室Motor 电机Main motor 主电机Load 载荷Over load 过载Motor load 电机负荷Rolling force 轧制力Rolling speed 轧制速度MPM: meter per minute 米/分钟Torque 扭矩Rated torque 额定扭矩Voltage 电压Process computer 过程计算机Program 程序，编程PLC：programmable logic controller 可编程控制器Encoder 编码器Information 信息Ghost rolling 模拟轧制Measuring instrument 测量仪表X-ray X射线Thickness gauge 测厚仪Width gauge 测宽仪HMD: hot material detector 热金属探测仪CMD: cold material detector 冷金属探测仪Light barrier 光栅Automatic model 自动模式Semi-auto model 半自动模式Manual model 手动模式Emergency 紧急，急停Joggle 点动HMI：human machine interface 人机界面AC frequency converter 交流变频器I/O：input/output 输入/输出端口Step control 卷取机助卷辊的“踏步”控制Hydraulic system 液压系统Grease 甘油Oil 油，稀油Oil station 油站SSC: Short stroke control 短行程控制AGC: automatic gauge control 自动压下控制AWC: automatic width control 自动宽度控制Pump 泵Screw pump 螺杆泵Filter 过滤器，滤网Cylinder 液压缸，圆柱体Valve stand 阀台Accumulator 蓄能器Leakage 泄漏Product 产品Grade 钢种Batch 一炉，一批Batch No. 炉批号Coil 钢卷Strip 带钢，薄带钢Sheet 钢板，薄钢板Plate 中厚板Physical performance 物理性能Mechanical performance 机械性能Strength 强度Elongation 延伸Flatness 平直度Plasticity 塑性Crown/chamber 凸度Hardness 硬度Microstructure 微观组织结构Austenite 奥氏体Ferrite 铁素体Pearlite 珠光体Deep drawn 深冲SPHC 普通级热轧钢板（卷）SPHD 深冲级热轧钢板（卷）SPCC 普通级冷轧钢板（卷）SPCD 深冲级冷轧钢板（卷High strength low-alloy steel 低合金高强度钢Silicon steel 硅钢，电工钢Galvanizing 镀锌Coating 涂镀，涂层Heat treatment 热处理Aging 时效处理Annealing 退火Quenching 淬火OtherAlarm 报警Anchoring bolt 地脚螺栓Yield 产量，成材率Ton 吨Annual 一年的Month 月Day 日Shift 班Safety 安全Radioactive hazard 放射性伤害Caution 注意，小心Layout 平面布置Document 文件Documentation 技术文本，技术文件报价书TOP: take-over point 交接点IC Initial conditions 初始条件PC Permanent conditions 固定条件MAN Manual run 人工运行AUTO Automatic run 自动运行HS High speed 高速LS Low speed 低速VLS Very low speed 爬行FWD Forward 前进REV/BWD Reverse – backward 后退DS Delayed stop 延时停车NS Normal stop 正常停车FS Fast stop 快停ES Emergency stop 急停RM R oughing mill 粗轧机RCS Roll Change Side 换辊侧DS Drive side 传动侧。

polished 抛光,water polished 水流（水压）抛光和handle polished 手工抛光Weld 焊接Outside diameter 外径Wall thickness内壁厚度Seamless pipes无缝管Polish抛光Pickling酸洗Corrosion-resistant防腐蚀Stainless steel round tubes不锈钢圆管Stainless steel square tubes不锈钢方管Rectangle tubes矩管Screwy tubes螺纹管Embossed tubes=empaistic tubes压花管FBizarre tubes异形管Tolerance公差Flat head平口steel钢Crude steel粗钢mild steel, soft steel 软钢，低碳钢hard steel 硬钢cast steel坩埚钢，铸钢stainless steel不锈钢electric steel电工钢，电炉钢high-speed steel高速钢moulded steel铸钢refractory steel热强钢，耐热钢alloy steel合金钢rolling mill轧机，轧钢机heating 加热preheating预热tempering回火temper回火hardening淬水annealing退火reduction还原cooling冷却rolling轧制drawing拉拔extrusion挤压wiredrawing拉丝coiled sheet带状薄板bloom初轧方坯metal strip, metal band铁带，钢带billet坯锭，钢坯shavings剃边profiled bar异型钢材shape, section型钢angle iron角钢plate, sheet薄板ferrite 铁素体austenite奥氏体martensite马氏体cementite 渗碳体iron carbide 渗碳体solid solution 固溶体sorbite 索氏体bainite 贝氏体forging 锻（件）casting 铸（件）rolling 轧（件）drawing 拉（件）shot blasting 喷丸（处理）grit blasting 喷钢砂（处理）sand blasting 喷砂（处理）carburizing 渗碳nitriding 渗氮creep 蠕变deflection 挠度elongation 延伸率alloy tool steel合金工具钢aluminum alloy铝合金钢bearing alloy轴承合金blister steel浸碳钢bonderized steel sheet邦德防蚀钢板carbon tool steel碳素工具钢clad sheet被覆板clod work die steel冷锻模用钢emery金钢砂ferrostatic pressure钢铁水静压力forging die steel锻造模用钢galvanized steel sheet镀锌铁板hard alloy steel超硬合金钢high speed tool steel高速度工具钢hot work die steel热锻模用钢low alloy tool steel特殊工具钢low manganese casting steel低锰铸钢marging steel马式体高强度热处理钢martrix alloy马特里斯合金meehanite cast iron米汉纳铸钢meehanite metal米汉纳铁merchant iron市售钢材molybdenum high speed steel钼系高速钢molybdenum steel钼钢nickel chromium steel镍铬钢prehardened steel顶硬钢silicon steel sheet矽钢板tin plated steel sheet镀锡铁板tough pitch copper韧铜troostite吐粒散铁tungsten steel钢vinyl tapped steel sheet塑胶覆面钢板Shrunk收缩Stave穿孔金GP-gold plated亮镍BRN-bright nickel黑镍BN(US15A)-black nickel亮铜BB(US3)-bright brass铜拉丝BB(US4)-brass brushed亮铬BC(US26)-bright chrome金拉丝GB-gold brushed镀镍NP-nickel plated镍拉丝NB(US15)-nickel brushed镀铬CP-chrome plated铬拉丝CB(US26D)-chrome brushed镀铜PB(US3-4)-plating brass不锈钢拉丝SSB(US32D)-stainless steel brushed 镀锌ZP(US2G)-zinc plated枪黑拉丝BNB-black nickel brushed铜抛光BP-brass polished青古铜AB(US10B)-antique bronze不锈钢抛光SSP(US32)-stainless steel polished 红古铜AC(US5)-antique copper不锈钢SS-stainless steel砂金SG-satin gold喷漆SPA(USP)-spray painting砂镍SN-satin nickel黑漆BL-black lacquer暗金（粉金）Dark GP-dark gold plated光亮漆BRL-bright lacquer。

钢铁行业专业英语A R steel 高温度锰钢abnormal steel 反常钢; 非正常钢aluminium-steel cable 钢铝电缆aluminized steel 涂铝钢aluminum nickel steel 铝镍钢anchored steel trestle 锚固式钢栈桥angle steel ruler 钢角尺anisotropic steel 各向异性钢片anisotropy silicon steel 各向异性硅钢片annealed sheet steel 退火薄钢板annealed steel 退火钢; 韧钢anti-creeping angle steel 防爬角铁anticorrosive aluminium-coated steel wire防蚀镀铝钢丝arc-furnace steel 电炉钢arc-welded steel pipe 电弧焊接钢管area of steel 钢筋断面面积; 钢筋截面面积area of structural steel 型钢截面积Armco aluminized steel 阿姆柯渗铝钢armco aluminized steel 表面浸镀铝钢Armco stabilized steel 阿母柯稳定化钢Armco steel 阿姆柯软钢armco steel 不硬化钢austenilic Ni-Cr stainless steel 奥氏体镍铬不锈钢austenitic alloy steel 奥氏体合金钢austenitic chromium-nickel steel 奥氏体铬-镍钢字串7 austenitic clad steel 奥氏体复合钢austenitic heat-resistance steel 奥氏体耐热钢austenitic manganese steel 奥氏体锰钢; 哈德菲尔德锰钢austenitic stainless steel 奥氏体不锈钢austenitic steel 奥氏体钢automatic steel 易切削钢automatic(al) steel 易切削钢axle shaft steel 车轴钢axle steel 车轴钢钢铁业的英语词汇1Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Case-Hardened Steel 表面渗碳硬化钢; 渗碳钢Bolts & Nuts For Steel Slotted 角钢螺丝Cast Alloy Steel Piston 合金铸钢活塞Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 铸造不锈钢Cast Steel 铸钢件Cast Steel Plate 铸钢板Cast(Carbon) Steel 铸钢Cast-In Steel Bush 铸入钢套字串2Casement Section Steel 窗框钢Cast-Steel 铸钢Cast-Steel Crossing 铸钢辙叉Cast-Steel Pipe 铸钢管Cast-Steel Separator 铸钢隔板; 铸钢横梁Cast-Steel Shot 钢砂Cast-Steel Yoke 铸钢轭Cellular Steel Floor 格型钢楼板Cement-And-Grouted Steel Bolt 钢筋砂浆锚杆Cemented Steel 表面硬化钢Cemented Templet Steel 渗碳样板钢Centra Steel 球状石墨铸钢Centrifugal Steel 离心铸钢Centrifuge(D) Steel 离心铸造钢Channel Steel 槽钢Channel-Section Steel 槽形钢Channeled-Steel Wheel Rim 槽钢制轮辋Checkered Steel Plate 花纹钢板Chemical Capped Steel 化学封顶钢Chilled Cast Steel 冷硬铸钢Chilled Hardened Steel 淬火钢Chilled Steel 淬火钢; 淬硬钢Chisel Steel 凿钢; 凿子钢Chrome Hardened Steel 铬硬化钢Chrome Steel 铬钢Chrome-Carbon Steel 铬碳钢Chrome-Manganese Nitrogen Steel 铬锰氮钢Chrome-Manganese-Silicon Alloy Steel 铬锰硅合金钢Chrome-Molybdenum Steel 铬钼钢Chrome-Nickel Steel 铬镍钢字串5Chrome-Plated Steel Nozzle 镀铬钢喷管Chrome-Silicon Steel 铬硅钢Chrome-Tungsten Steel 铬钨钢Chrome-Vanadium Steel 铬钒钢Chromemanganese Steel 铬锰钢Chromium Nickel Steel 高强度耐蚀铬镍钢Chromium Stainless Steel 铬不锈钢Chromium Steel 铬钢Chromium-Molybdenum Steel 铬钼钢Chromium-Nickel Steel 铬镍钢Chromium-Plated Mild Steel Animal Chain 镀铬软钢动物链条Chromium-Tungstenvanadium Steel 铬钨钒钢Chromiummanganese Steel 铬锰钢Chromiumnickel Austenite Stainless Steel 铬镍奥氏体不锈钢Chromiumplated Thin-Walled Steel Cylinder Liner 钢质薄壁镀铬汽缸衬套Chromized Steel 渗铬钢Circular Steel Support 环形金属支架Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel 包覆钢Cladding Steel Sheet 复合钢板Clean Steel 纯净钢; 洁净钢Closed Die Steel 闭锻模钢字串8Coarse-Grained Steel 粗晶粒钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧钢Cold-Rolled Carbon Spring Steel 冷轧弹簧碳钢Cold-Rolled Carbon Steel 冷轴碳钢Cold-Rolled Steel Strip 冷轧带钢Cold-Shaping Steel 冷变形钢Cold-Short Steel 冷脆钢Cold-Steel 利器Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Coldshort Steel 冷脆钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Column With Steel Hooping 螺旋箍筋柱Combined Steel And Concrete Column 钢骨混凝土柱Comminuted Steel Shot 钢粉Common Straight Carbon Steel 普通碳素钢Complex Alloy Steel 多元合金钢; 合金钢碳素结构钢 Carbon Construction Steel碳素工具钢 Carbon Tool Steel合金结构钢 Alloy Construction Steel合金工具钢 Alloy Tool Steel高速工具钢 High Speed Tool Steel弹簧钢 Spring Steel不锈耐热钢 Stainless & Heat Resisting Steel轴承钢 Bearing Steel字串3工字钢 Ibeam普通圆钢 Round Steel槽钢 Channel扁钢 Flat Steel Bar等边角钢 Equal Angle Steel不等边角钢 Unequal Angle Steelh型钢 Hbeam钢坯 Billet,Bloom钢筋混凝土用变形钢筋 High Strength Deformed Steel Bar 窗框钢 Window Sash中厚钢板 Steel Plate热轧钢板（卷） Hot Rolled Steel Coil冷轧钢板（卷） Cold Rolled Steel Sheel or Coil镀锌钢板（卷） Galvanized Steel Coil钢带 Steel Strip线材 Wire Rod Coil无缝钢管 Seamless Steel Pipe锅炉管 Boiler Tube石油套管 Pipe For Oil Field高压管 Pressure Pipe字串4高压气瓶用管 Tube for High-Pressure Vessel地质钻探用管 Seamless Steel Pipe For Geological Drill In 镀锌焊管 Galvanized Welded Pipe石油钻探杆 Drill Pipe For Oil Field铸铁管 Cast Iron Pipe重轨 Heavy Rail轻轨 Light Rail炼钢生铁 Basic Pig Iron铸造生铁 foundry Pig Iron普通圆钢钉 Round Nails for General Uses镀锌底碳钢丝 Galvanized Low Carbon Steel Wire.钢丝绳 Steel Wire Rope钢绞线 Stranded Wire预应力混凝土钢丝 Steel Wire For Prestressed Concrete窗纱 Window Screen车轮 Wheel Tyre轮筛 Wheel Circleiron and steel industry 钢铁工业字串9ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模 (美作:mold)tuyere, nozzle 风口ingot mould 锭模 (美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机字串8 drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬 (美作:blowtorch) crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿 (美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁字串8tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型 (美作:molding) calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝字串2blowhole 气孔钢铁业的英语词汇2Abnormal Steel 反常钢; 非正常钢Aluminium-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Anchored Steel Trestle 锚固式钢栈桥Angle Steel Ruler 钢角尺Anisotropic Steel 各向异性钢片Anisotropy Silicon Steel 各向异性硅钢片Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Anti-Creeping Angle Steel 防爬角铁Anticorrosive Aluminium-Coated Steel Wire 防蚀镀铝钢丝Arc-Furnace Steel 电炉钢Arc-Welded Steel Pipe 电弧焊接钢管Area Of Steel 钢筋断面面积; 钢筋截面面积Area Of Structural Steel 型钢截面积Armco Aluminized Steel 阿姆柯渗铝钢Armco Aluminized Steel 表面浸镀铝钢Armco Stabilized Steel 阿母柯稳定化钢Armco Steel 阿姆柯软钢Armco Steel 不硬化钢Austenilic Ni-Cr Stainless Steel 奥氏体镍铬不锈钢字串1Austenitic Alloy Steel 奥氏体合金钢Austenitic Chromium-Nickel Steel 奥氏体铬-镍钢Austenitic Clad Steel 奥氏体复合钢Austenitic Heat-Resistance Steel 奥氏体耐热钢Austenitic Manganese Steel 奥氏体锰钢; 哈德菲尔德锰钢Austenitic Stainless Steel 奥氏体不锈钢Austenitic Steel 奥氏体钢Automatic Steel 易切削钢Automatic(Al) Steel 易切削钢Axle Shaft Steel 车轴钢Axle Steel 车轴钢Bainitic Steel 贝氏体钢Balanced Steel 半镇静钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Bamboo Steel 竹节钢筋Band SteelBanding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Basic Bessemer Steel 碱性贝氏转炉钢Basic Bessemer Steel 碱性转炉钢字串7Basic Bessemer Steel Converter 碱性转炉钢转炉Basic Converter Steel 碱性转炉钢Basic Electric Furnace Steel 碱性电炉钢Basic Open Hearth Steel 碱性平炉钢Battened Steel Column 双肢钢柱Beam Steel Plate 大梁钢板Beam With Compression Steel 双筋梁Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Bent Steel 挠曲钢筋Bessemer Low Carbon Steel 酸性转炉低碳钢Bessemer Mild Steel 贝色麦钢Bessemer Steel 贝色麦钢; 酸性钢Best Plough Steel Wire 铅淬火高强度钢丝Billet Steel 坯段钢; 钢坯; 短条钢Binary Steel 二元合金钢Black Mild Steel Carriage Bolt And Nut 黑铁马车螺丝闩Black Mild Steel Fish Bolt And Nut 黑铁鱼尾螺丝闩Black Mild Steel Flat Head Rivet 黑铁扁头铆钉Black Mild Steel Flat Head Tinmen Rivet 黑铁号头铆Black Mild Steel Hexagonal Nut 黑铁六角螺丝帽Black Mild Steel Pan Head Rivet 黑铁锥头铆钉Black Mild Steel Round Head Rivet 黑铁圆头铆钉Black Mild Steel Square Nut 黑铁四方螺丝帽Black Steel Pipe 黑钢板Black Steel Sheet 黑钢皮Black Tin Steel 黑钢板Blister Steel 泡钢; 泡面钢Abnormal Structure Steel 反常组织钢Abrasion-Resistant Steel 耐磨钢Blue Steel 蓝钢Bluing Of Steel 钢加蓝Boiler Steel 锅炉钢; 锅炉钢Boiler Steel Plate 锅炉钢板Boiling Steel 沸腾钢Bolting Steel 螺栓钢Blue Planished Steel 发蓝薄钢板Bloom Steel 初轧钢; 钢坯Boron Steel 硼钢Brass Fitting Of Steel Window 钢窗铜配件Brass-Plated Mild Steel Round Bead Wood Screw 镀黄铜圆头软钢木螺丝Brass-Plated Mild Steel Round Head Machine Screw 镀黄铜圆头软钢机器螺丝Brass-Plated Steel Wire 镀黄铜钢丝字串9Brearley Steel 布里阿雷不锈钢; 布氏高铬钢Bridge Steel 桥梁钢Bright And Black Mild Steel Flat Head Tinmen Rivet 号头铆钉Bright Mild Steel Cotter Pin 光亮软钢开尾销Bright Mild Steel Countersunk Head Wood Screw 光亮软钢平头木螺丝Bright Mild Steel Hexagonal Nut 光亮软钢六角螺丝帽Bright Mild Steel Hexagonal Nuts 六角光螺帽; 六角螺丝帽Bright Mild Steel Hexagonal Pressed Nut 光亮软钢六角冲压螺丝帽Bright Mild Steel Round Head Wood Screw 光亮软钢圆头木螺丝Bright-Drawn Free Cutting Steel 光拉自由切削钢Bright-Drawn Steel 光亮拉拔钢材Bright-Finished Steel 光亮精整钢Bristol Steel Belt Lacing 布瑞斯涛钢带接头Bronze Steel 镀青铜钢Building Of Steel Frame Construction 钢框架房屋Bulb Steel 球扁钢Bulb-Rail Steel 球头丁字钢Burned Steel 过烧钢Calorized Steel 涂铝钢; 渗化钢Calorizing Steel 铝化钢字串9Capped Steel 加盖钢; 半镇静钢Carbon And Low-Alloy Steel Vessels 碳钢及低合金钢容器Carbon Content Of Steel 钢含碳量Carbon Molybdenum Steel 钼碳钢Carbon Steel 碳钢; 碳素钢Carbon Steel Covered Electrode 碳钢焊条Carbon Steel Plate。

(aluminium) killed steel （铝）镇静钢1b 磅abbreviation 缩写abrasion-resistant 耐磨损的A-C vector driver 交流向量驱动access 使用或进入之途径，通路accessibility 可达性，可接近性accessory (attachment)accommodate 供应accomplish 完成accumulator 活套accuraccy 准确性，精密性ACFM average cubic feet per minite 平均立方英尺/分钟1立方英尺=35.3147立方米acid concentrate 酸浓缩acid contaminate waste water 酸污染废水acid fume 酸雾acoustic 听觉的、声学的actual 真实的actuate 开动,使动作,作用,励磁acuator 调节器,激活器,执行机构adapter 联接器，接合器adequate 充足，适当adjacent 邻近的administration 行政管理AGC automatic guage controlagency 机构agitation 摇动air box 风箱air compressor 空气压缩机air duct 风管，通风管道air oven 热空气干燥炉algorithm 计算法align 使成一条直线，对准，校直alignment 调整，排成直线alkaline 碱的、含碱的alkalinity 碱度allowance 许可，承认，余量alpha/numberic 字母数字混合编排的alternate 交替altitude 高度alumize 铝化，渗铝ambience 环境温度ammonia 氨气anchor 锚，固定器，支座ancillary 辅助的,附属的angle bar 三角铁annealing pickle lineannealing treatmentANSI American National Standards Institute美国国家标准协会anticipate 先做，盼望anti-finger steel plate 耐指纹钢板antirust oil 防锈油appertain 所属appliance 器具applicable 适用的applicator roll 涂覆辊appropriate 适当的approve 批准，认可，赞成archival 档案的arrangement 排列，布置，配置，装配，安装as-built drawing 竣工图ASC automatic shape controlassembly 部件，组件，装置，组装assembly parts 组合件assessment 评价assistance 帮助assume 假定atomize 雾化attain 到达，得到authorize 批准，授权automatic coil bending station 带钢自动打捆站auxiliary 辅助的availibility 有用的，可资应用性，利用率，有效性axis 轴back tension 反张力back-up roll 支撑辊backward curve type fan 后曲叶片式风机backward-inclined type fanbaffle plate 挡板banding strap 捆带base frame 底座base strip(plate)batch annealing 罩式退火battery limit 界区bay 跨beam 光线，横梁，照射bearing 轴承bearing chockbearing race 轴承座圈bearing-load-distribution 轴承载荷分布bed plate 底板，地脚板（轧机）belt wrapper 皮带助卷机bench levelbench mark 水准点,基准bilateral tradebillet 方坯bite 辊缝，咬入bivalent 二价bladder 气囊blade 刀峰bloom 大钢坯、钢锭、初轧方坯board 配电盘board chair 董事长bogie 转向架boiler 锅炉，汽锅，蒸煮器boiling steelborer 镗床brace （支持，拉紧，振奋）斜撑，支柱，系杆，手摇钻brake 煞车器，掣动，煞车breaker roll 破鳞辊bridle set 张紧装置bright annealing 光亮退火bronze 青铜bronze bushing 青铜轴套BTU British Thermal Unit 英国热量单位 1BTU=262Kbuckle 中间浪,皱,纹buffer 缓冲器bumper 保险杠、消音器buna 丁（二烯）钠（聚）橡胶，布纳橡胶bundle （光、维管、波）束、捆、扎burr,flash 毛刺bush(ing) 轴套，轴衬，衬瓦，（电）绝缘套管butt welding 对焊by means of 用、、、的办法cable rack 电缆架calcium 钙calibration 标准、校准caliper 卡尺、卡盘；制动卡盘callout 插图的编号calorific 生热的cam 凸轮，;偏心轮，样板，靠模，仿形板cam roller 凸轮辊camber 翘曲镰刀弯carbon block 碳精块carbon dioxidecarbon monoxidecarriage 搬运车carry over table 运输辊道carryover-conveyor 转换运输机cartridge 卡盘,暗盒cascade 级联，小落瀑casing 套罩、箱外壳、套管cast 熔炼，铸造，铸件，[冶]浇注，铸锭，炉次cast iron 铸铁casting 浇铸catalogue 目录，编目录catalytic 催化的catenary 悬索，[压]（带钢）垂度，弛度caustic 腐蚀性的cell 光电元件central pipe 中心缩孔(缩管)centrifuge 离心ceramic 陶瓷chain conveyor 链式运输机check valve 逆止阀，止回阀chemical constitution 化学成分chloride 氯化物chop 碎断chrome 铬chronological 编年的chute 槽，斜槽，滑槽，溜槽circuit breaker 断路开关，断路器circular shear 圆盘剪circumference force 切向力civil work 土建clading,film 镀层clam 夹具，台虎钳，钳子，夹子clamp 老虎钳，钳clearance 余隙，间隙，清除，扫除，许可clutch 离合器coarse 粗糙的coefficient 率，系统coil break 横褶纹coil centering 带卷定心coil peeler 带卷直头机cold drawn 冷拔Cold Laminator 冷覆膜机cold rolled stripcold tandem millcollapse （坍，崩溃），回缩collapsible 折叠的，胀缩的colour coated stripcolumn 柱子，栏，塔，蒸馏塔，萃取塔，吸咐塔combustion 燃烧comment 评注，批评commission 使用(试运转)compatible 兼容的compensate 补偿，均衡，校正，（金属，合金的）调质compensator 膨胀圈,膨胀接头compliance 顺从concentrically 同轴的concrete 混凝土condenstate 冷凝，回流conductivity 传导率，电导率，传导性，导电性，导热率conduit box 接线盒consective 连接作用consideration 考虑consistent 一致的console 控制台，仪表板consortium 合伙constrain 强迫、压制、束缚、约束construct 构造物，建造，构成consume 用尽，毁灭contamination 污染、玷污、放射性污染、混淆contour 轮廓线,外形,等高线contract 合同，协议contractor 立契人，承包商control cubicle 控制柜control valve 操纵阀，控制阀convection 对流conversion 转变conversion coating 转换层（辊涂后）convertor 转炉conveyor 运输机，输送机，传送机，移送机coordination 调整,配合corrosive 腐蚀性的corrugate 瓦楞、波纹council 委员会，政务会coupling section 连接部分cover plate 盖板CPL continuous pickling line 连续酸洗生产线cradle 支架，摇架cradle rolls 托卷辊crate 大板条箱，用大板条箱装crimping 皱褶，波纹crop shear 切头剪cross-tie 枕木，轨距，连杆，横向拉杆，横木curcuit 电路，回路，系统，流程，循环customs inspection 海关检查cutting gap 剪切间隙CVC continuous variable crown 连续可变凸度cyclone 旋风,离心除尘cylinder block 缸组，缸体dam up 筑坝，阻止damper 阻尼,缓冲,减震器,风门DC bus 直流母线debrics 碎片、屑deburring 去飞边，去毛刺，去毛边decarburization 脱碳deck 盖，甲板，桥面，台面dedicate 供奉，奉献deflector 导向挡板degree of finish,smoothness 光洁度deionize water 无离子水，脱离子水deliberate 考虑、斟酌delivery coil car 出口带卷小车delve 挖掘、钻研denominate 命名depict 描绘、描述depletion 消耗，排除deploy 展开、部署、调度deposition 沉积，沉淀，析出designation strip 名牌、标签detergent 清洁剂、除垢剂dethreading 甩尾deviation 偏差,漂移dew point 露点diagnostic 有助于诊断diaphragm 隔板、挡板、孔板differential 微分discharge pipe 排出管disconnect 拆开，使分开（离）disconnected-switch 隔离开关discreeet 考虑周到的，谨慎的discrepancy 不同disengage 解脱，松开Disk Brake 盘式制动器dismantling stooldissipation 消散,消耗,损耗distill 蒸馏除去distribution thansformer 配电变压器dividing shear 切分剪downpayment 定金drainage 排水,阴沟draw off 抽取，排泄drive spindle 传动轴drop separatordrum 圆筒，鼓drum shear 滚筒剪duct 管道ductile 可延伸的ductile iron casting 球墨铸铁件due time 到期durability 耐久duty-cycle 工作循环，工作周期dynamically balanced 动平衡economic benefiteddy-current test 涡流探伤edge drop 边部减薄EDM=Electron Discharge Machining 放电加工EDPM 三元乙丙橡胶elaborate 详细拟定elapse 过去、消逝elastic constantelastic deformation 弹性畸变electrical room 主电室elevation 高度，高处，提升，正面图，立式图elevator 升降机，电梯elongation percentage 延伸率embed 安插，埋置Embosser 热压花机empiric 根据经验的emptying 沉淀物emulsion 乳剂encapsulation 密封、包胶enclosed speed reducer 全封闭的减速机enclosure 套，盒，箱，包围，围绕，封入，外壳endless belt 两头对接的环带endurance 耐久力endurance limit (fatigu limit ) 持久极限，疲劳极限engage （齿轮）啮合，使紧密联接ensure 保证entry guid 入口导轨EPOXY Resin (EP) 环氧树脂equalizer 均衡器equivalent 当量，等效值erection schedule 安装进度erection supervision assistance 制造监理ergonomic 人体工学、工效学、人与机械控制ethernet 以太网evaporator 蒸发器eveness 均整性evolve 发展、进化、离析、引申excavation 挖掘excentricity 偏心exclusion 排斥exert 发挥,尽力expanding cylinder 膨胀缸expansible coil preparatory coiler 胀缩卷筒式带材预卷机explosion 爆炸explosion proof lighting 防爆照明extractor 提取、萃取器、抽提塔extrusion 挤压fabricate 构造、建造、杜撰fabricate 建造fabricated steel construction 预制钢结构Fabricated Frame 预制钢结构facilitate 使变的容易的，促进factor 系数，因素，因子，因数，乖数feed table 进料盘feed-forward 前馈ferritic 铁素体ferrous 含铁的、铁素体的festoom 花彩、垂花饰fillet （模型或芯盒上的）圆角条，倒圆角，嵌条finishing coat 面漆finishing machining 精加工finite element method 有限元法fittings 配件，连接件，零件，器材，仪器fixture 设备，夹具，装置器flange 法兰flap 片状悬物,舍阀,舍flattener roll 矫直辊flexible 伸缩自如的，柔性的float valve 浮筒阀flowrate 流量，流速FLT full load torquefluctuation 波动、摆动flue gas 烟气fluid 流体fluorocarbon 碳氟化合物flying crank shear 曲柄式飞剪FOB freight on board 离岸价格foil 压薄、薄片forged 锻造的fork lift 叉车foundation 地基，基础fracture 破裂、断口friction 摩擦friction factorFSIR full spectrum infraredfuel 燃料fulcrum 支点fused switch 熔断开关galvanized sheetgangway 通道,过桥gap 辊缝gasket 衬垫，垫圈gauge 规格，估计，量规计gear case 减速箱壳gear rack 齿条girder 梁,垳架gloss range 光泽度范围gradient 梯度granite 花岗岩grate 铁栅栏，格栅grease lubrication 干油润滑grid 栅格grinder,grinding machine 磨床grit blast, spray sand 喷砂，喷丸groove 凹槽gross 总重grounding cables 接地线grout 灌浆guard 保卫，防护，挡板gutter 阴沟、水槽hand railing 扶手，栏杆hand-over position 交接区harmonic 谐波headquarter 总部、司令部heat expantionheating furnace 加热炉helical 螺旋的，螺线，螺旋线（面，形，状）helid 氦化物heoprene 氯丁（二烯）橡胶hermetical 密封的herringbone 人字形hierarchical 阶级的high dynamically loaded bolt 高强螺栓high order 高位,高次high pressure hot waterhinge 铰链、铰接histogram 直方图historical 史学的hoist 起重机hold-down roll 压紧辊homogeneity 同质、均匀性、齐次homogeneous 同族的、单一的、同次的hood 罩，盖，帽，烟罩，通风，橱horn 警报器hose 软管，用软管引水hot rolled striphousehold [electrical] appliance 家电housing 框架HTR High Tech Rolling humidity 潮湿hung 悬挂了hydralic bolt tightener 液压扳子hydralic screwdown 液压压下hydraulic accummilator 蓄能器hydraulic cylinder 油缸hydridehydrochloric acid 盐酸hydrogen 氢气hydrostatic lubrication 静液压润滑hypalon 氯磺化聚乙烯橡胶hypothesis 假设hysteresis 滞后I.D. indetification idle roller 空转轮，惰轮ignition hood 点火器immersion cell 沉浸槽impact 撞击impart 分给impeller 推动者（器）叶轮impinging flow 射流in accordance with 依据inaccessible 达不到的，难接近的incorporate 合并indication 表示，象征indispensable 不可缺少individually 单独地inductive 电感，归纳（法）的inert gas arc welding 惰性气体保护(弧)焊inertia 惯性，惯量infrared ray 红外线ingot （铸）锭inhibit 制止，禁止initiate 引发，使入会，开始inlet side 入口侧inspection 视察，检查instrumentation 器械操作，仪器，仪表insulation 绝缘，绝热integrate 整合，集成intensity 强度，强烈，剧烈interchangeability 可交换性，互换性intercom 室内对讲对话，内部通信装置interconnecting piping 连通管路interface 接口interlock 连索互结intermediate roll 中间辊interrogate 询问、质问intervention 介入、调停、干涉inverter 换流器，变换器，反相器，转换开关ionize 电离isolating transformer 隔离变压器isolation transformer 隔离变压器jack scraw 千斤顶螺杆，起重螺杆joint shaft 接轴junction box 汇接室，分线箱，接线盒，套管，连轴器keeper plate 轧辊轴承座压板kick off meeting 首次会议L/C lisence credit 信用证laminar 层片、叶片lap welder 搭接焊lateral 侧面的layout 布置，规划，设计lean gas 贫（瘦、干、废）（煤）气least square 最小二乘ledge 横档，壁架levelling instrument 水准仪light-gauge 薄尺寸lightning 雷,闪电limb of electromagnet 电磁铁铁心limit switch 极限开关，终点开关linkage 连接，链系，联动装置，杠杆机构liquid nitrogen 液氮lithium chloride 氯化锂load cell 测压仪，测力计，发送器loading skid 装载滑轨lockout relay 连锁继电器longitudinal 轴向的，长度的lower limit of strengthLPG liquefied petroleum gas 液化石油气machinical propertymagnitude 大小，数量，等级make-up air 补给空气malfunction 不正常工作、动作失调mandrel diameter 芯轴直径manhole （检修用）人孔，检查孔，舱口manifold 集管,多头导管marine 海的，海（磨、冲）蚀martensitic 马氏体masher 捣碎mashine steel 机械（零件）用钢(0.2-0.3C)mass moment of inertia 质量惯性矩mass ratio 始末质量比mass/volume flow control (VFC)质量流控制matrix 矩阵，发源地，模型mature 成熟的measuring staff(rod) 测量棒mechanism 机构，机械装置，机理melting point 熔点metallurgy 冶金学metastable 亚稳定mezzaine 夹层、中层楼mica 云母mild steel 低碳钢mill length 轧制长度miller 铣床misalignment （中心线）未对准，不重合，mitigate 减轻、缓和moment 矩,动量Monorail Structure 单轨结构件Morgoil bearing 油膜轴承mortar 灰浆Mota 锡基高强度轴承合金mould typemounting 装置MTBF mean time between failure平均故障影响时间muffler 消声器multiple 多重的，复合的，倍数naphthalene 萘NEMA National Electrical Manufacturers Association（美国）全国制造商协会neoprene 氯丁橡胶、氯丁二烯niobium[nai5EubiEm] 铌nip 咬入、辊隙nipple 喷嘴,螺纹接套nitrile 丁腈橡胶nom 公（标）称nominal value 额定值、标称值normalise 正火notch 缸口，刻痕，凹槽，嘴子numeric 数字，数值，分数，不可通约数obstruction 阻碍、妨碍occupational 职业的off-load 卸载optimum 最好条件option 挑选物，选择，选择权organic 有机的orifice 洞，孔orifice meter 孔板流量计O-ring seal 圆环密封ovality 椭圆度oven inner liner 加热炉内衬over picklingoverhead craneoverhung 悬垂的overlap 重叠over-run 超程overspill 溢出，溢出物，溢流，[机]排出润滑油overwind 上开卷oxideoxygenp.f. power factor 功率因数packing 包扎，打捆，填料，衬料pad 底垫，衬垫，垫料，垫片，垫圈padlock 挂锁paint 漆panel 板，盘，屏，开关板，控制板，配电盘parabolic 抛物线parallel 平行的，相同的parameter tableparticulate 粒子parting shearpass 孔型,轧槽,道次pass line 轧线patent 专利pay-off coiler 开卷机pay-off cradle 开卷箱座pay-off drum 开卷机卷筒pay-off housing 开卷机机架pay-off reel 开卷机penertation 渗透permanent 永久的permit [环保](废物排放)许可证perpendicular 直立的，垂直的personnel 人员，职员pertiment 适当的、贴切的、相应的petroleum 石油phenolic (苯)酚photocell 光电元件photo-electric 光电（效应）的PI diagram piping and instruments diagram pickling bath 酸洗槽piling 打桩pillar 支柱、墩pillow block 枕垫、垫块pilot flame 引燃火舌pilot valve 导阀,辅助阀,控制阀pilot-pin 定位销pin 针，销，细杆，旧棒pinion 传动齿轮，小齿轮piston rod 活塞杆pivot 轴尖、枢轴pivotable guide table 绕枢轴旋转的导板台planer 刨床plasticityplatform 场，平台，站台，装卸台plausibility 似乎合理plot 绘图、曲线、地块plug 塞子ply 层，厚度plywood 夹板，层板pneumatic 气动polypropylene 聚丙烯polyurethane 聚氨基甲酸（乙）酯portuguese 葡萄牙的（人）positive 明确的，正的，阳性的PP pressure-proof 耐压的PP plastic product 塑料制品pre-assembly method 预置装配法precise 精确的preliminary 初步，开端pressductor 压力传送器pressure reducer 减压阀pressure switch 压力开关，压力继电器pressurization 加压prevail 成功，流行，胜过primer 底漆primer base 底漆涂料prior 在先的procurement 采购,获得profile 板形property 性质proprietary 专利的province 职权范围provision 供应，规定，预备proximity switch 接近开关PTFE 聚四氟乙烯pulley 滑轮,滚筒purchase 换取，购买purge 吹扫、清洁pushbotton 按钮，电钮pvc (polyvingl chloride ) 聚氯乙烯quarter 1/4 浪quench 淬火quenching and temperingrack 架子，齿轨rack-and-pinion 齿轮齿条rate 估价，比率rated 额定的，标准的reaction equation 反应方程式reactive power 无功功率recess 凹进处，凹口，凹槽，退刀槽recovered acid 回收的酸rectifier [电]整流器，检波器recuperate 回收、余热利用redundant system 冗余系统reel mandrel 卷筒reflective 反射的regressive 回归regulation 规则，管理regulator 调节器，调节装置，稳定器reinforced concret 钢筋混凝土relative humidity 相对湿度release 释出，解除联锁断开relief valve 安全阀，保险阀remote I/O rack 远程输入／输出机柜removal 移动reserve volume 储备量reservior 容器、贮水池、水箱residul error 残留误差resistance of deformationresonant frequency 谐振频率responsibility 任务，责任rest 支撑retention 保留，滞留（物）retract 伸缩revamping 修补、改造reversible 可逆的rewind 重卷，重绕ridge 屋脊、山脊rigid 刚性rigidity 刚性rinse 冲洗，轻冼RMS root mean square value均方根，有效值roll barrel 滚身roll bearing 轧辊轴承roll neck 辊颈roll wear 轧辊磨损roller bearing 滚柱轴承roller chain 辊子链rolling radius 轧制半径rolling schedule 轧制程序表rolling solution 轧制工艺润滑冷却液rolling speedrolling stock 机动车辆,轧制毛坯rope pulley 绳轮rough machining 粗加工roughness 粗糙度rubber lining 橡胶衬里saddle 马鞍，鞍状物safety coupling 安全连轴器safety guard 安全设施，保险板sample preparetion 取样sanitary 公共卫生的,消毒的,公共厕所satisfactory 今人满意的saturation 浸透，饱合，饱合状态scaffold 脚手架scale exhaust 除鳞scale layer 鳞层schematic drawing 示意图,结构图,原理图scrap bucket 废料斗（槽）scratch 擦痕screw down 螺旋压下机构screw jack 螺旋千斤顶scrubber 洗涤器seal 封闭seamless 无缝的，整拉的sectional steel 型钢segment 弓形体，扇形体，段，节，片seismic coefficient 地震系数self-commuted 自换向self-tuning 自调seperating disc 分离圆盘service factorService Hoist 电葫芦shallow tank 浅槽shield 防护，屏蔽，护罩shield gasshift 移动shim 垫片shock absorber 减震器shrink 收缩，退缩，缩水shroud 罩shuttering 模板shuttle 棱，来回移动sickle shaped 镰刀弯side guide 侧导轨side trimming 齐边side-set cylinder 横移液压缸sight 观察silicon dioxidesilicone modified polyester 硅改性树脂sinter plant 烧结厂skew 斜、不对称Skew/Synchromous Run Controlskid 刹车，刹着车滑走slab casting 板坯连铸slabing 板坯sleeve 套筒slice 薄片slide vavle 滑阀sliding base 导向轨座（机座可以沿其移动）sliding frame 滑座sling 吊索slitting shear 纵切slope 坡道，斜面，坡度，斜度sludge 淤泥、残渣SMPS switch-mode power supply开关电源snubber roll 缓冲辊,减震辊,抱辊soleniod valve 电磁阀solution treatment 固溶处理spangle 锌花spare part 备件spark-ignited 电火花点火specific weight 比重specification 规格，说明书spectrum 谱、光谱speed cone 变速锥spindle carrier 接轴托架spindle nose 轴头spiral conveyor 螺旋型运输机splash 飞溅splice 接合、拼合split-out 分交spray-off 喷射spring equation 弹跳方程sprocket 链（星）轮、链轮铣刀squeezing roll 挤干滚stage 步骤，时期，阶段stagger 交错、间隔stainless steel construction 不锈钢结构stairway 楼梯stand-by 备用standstill 停歇start-up 开动，起动，开工，投产statically balanced 静平衡statics 静力学stationary 固定的steel grade and typesteering cam 导向凸轮stepwise 逐步stiffner 加强筋stipulate 规定stock 贮备，储存storage 仓库，存贮strainer 过滤器strap 带子，用带子捆扎strapping machine 捆扎机strategic 要害的，战略的stress free 无应力stress-strain 应力应变stringent 严格的、精确的stringer 发纹（金属缺陷）strip camber 板凸度strip clamping device 钢带夹持装置strip deviding speed 开卷速度strip processor 直头机strip tensiometer roll 带材张力测量辊strobe 闸门，选通（读取）脉冲，频闪观测仪strobe light 频闪闪光灯stroboscope 频闪观测器，闪光仪stub-out 短管接头sub-base 基础下的卧,地盘座（机器）sufficient 充分的，足够的sulfate 硫酸盐sump pump 油池(排积水)泵superordinate 等级高的,使升级supervision 监督，管理supportor supporting framesuppression 抑制suspend 吊，悬浮swing 摇摆，摆动，振（摆）幅swirling 漩涡switch board 配电盘switch-over 换向swivel cylinder for strip track control 带钢跟踪装置控制用旋转缸symmetrical 对称synthetic [金]结晶体，[化]合成物，合成的tag 标签、电缆接头、标记、标识tail out 脱尾take-over-point 接点tap changing 抽头转换taper 尖锥体，锥度tar 焦油tare 皮重,包装重task 工作，任务TCM Tandem Cold Milltelescoping finished coil 塔形卷tempering 回火、调合、光整tensile strength 抗拉强度tension briddle 张紧辊tension leveller 张力平整机tension reel 张力卷取thermal flatness controlthermocouple 热电偶thermostat 恒温器、双金属片thread 螺纹，车螺纹，攻丝，，螺线threading 穿带throughout 到处，始终，贯穿，遍及thrust bearing 推力轴承tightness 密闭性tile 瓦片，板tinned strip 镀锡板titaniumtoe-board 底板touch up 修整,修饰track,railtrade agreement 贸易协定trailer 拖车transformer 变压器，变量器traverse 横的，横越tray 盘，垫座，托架tread 踏板trickle 滴下、淌trimming 装饰tripod 三角架trivalent iron 三价铁trouble free 无故障的，不间断地tubular 管形的，空心的tungsten 钨turn stile 旋转栅门turnkey contract 交钥匙合同twin drive 双电机驱动tying machine 捆扎机UC universal crown unabated 未减弱的、不减少的undertake 承担uniform 一致的，不变的，制服union 联接，结合，联接器，管接头uniterruptable power supply UPSuniversal joint 万向接头unloading valve 放泄阀up-coiling speed 卷取速度utility 公辅设施UV ultraviolet 紫外线vacuum degas 真空脱气valve stand 阀站VC variable crown 可变凸度vector 向量vendor 买方，出买人ventilation 流通空气，通风设备vessel 容器volatile organic compound VOC 挥发性有机成份voltage 电压walking beam 步进梁warrant 保证，执照，许可证watch dog 监视、监控wave edge 边浪wave middlewear 磨损，磨耗wedge-shape 楔形weld seam 焊缝welded steel structure 焊接钢结构wet bulb temperature 湿球温度winch 卷扬机,绞车;曲柄wind box 风箱winding 绕，卷绕，弯曲window layout 窗口布置wind-up 完结,装有发条的wiring 接线wolfram 钨work roll wear 轧辊磨损workmanship 手艺，本领，作品，技巧wrap angle 包角wrap,curl,buckle,camber 翘曲wringer roll 挤干辊wye 星形连接、三通yeild limityeild ratio 屈强比yeild strengthyield point 屈服点zirconium 锆。

1 炼焦炼焦coking高温炭化high temperature carbonization 塑性成焦机理plastic mechanism of coke formation 中间相成焦机理mesophase mechanism of coke formation选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke 焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂?coumarone-indene resin 精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青?coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina 电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker 合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite 硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning 死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick 泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle定径水口metering nozzle氧化铝-碳化硅-炭砖?Al2O3-SiC-C brick 透气砖gas permeable brick,porous brick 滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory 轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance3 碳素材料[含]碳[元]素材料?carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization 石墨纯净化处理purification treatment of graphite炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode 石墨电极接头graphite electrode nipple 石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium 微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process 电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore 块矿lump ore粉矿ore fines矿石混匀ore blending 配矿ore proportioning 矿石整粒ore size grading 返矿return fines储矿场ore stockyard 矿石堆料机ore stocker 匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime 有机粘结剂organic binder 烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine 环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler 环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates 生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing 链算机-回转窑陪烧球团grate-kiln for pellet firing 环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite 铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate 硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet 金属化球团metallized pellet 转鼓试验drum test,tumbler test 落下试验shatter test6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging 无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace 探料尺gauge rod利用系数utilization coefficient 冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone 渣比slag to iron ratio,slag ratio 上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume 工作容积working bolume 铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler 渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling 热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove 顶燃式热风炉top combustion stove 炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making 直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace 流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making 熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process 连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation 还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials 添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygenfurnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE 顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration 吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance 多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector 废气控制系统off gas control system,OGCS 平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace 直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,VAR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC 等离子凝壳铸造plasma skull casting,PSC 能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization 鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,VAD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH 循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作?RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argonbubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD 氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster[连铸]流strand铸流间距strand distance注流对中控制stream centering control 钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation 结晶器内钢液顶面meniscus,steel level 钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device 钢流保护浇注shielded casting practice 多点矫直multipoint straightening 电磁搅拌electromagnetic stirring,EMS浇注周期casting cycle多炉连浇sequence casting 事故溢流槽emergercy launder 菜花头cauliflower top钢锭缩头piped top表面缺陷surface defect内部缺陷internal defect缩孔shrinkage cavity中心缩孔center line shrinkage气孔blowhole表面气孔surface blowhole 皮下气孔subskin blowhole针孔pinhole铸疤feather冷隔cold shut。

1. indication 缺陷2. test specimen 试样3. bar 棒材4. stock 原料5. billet 方钢，钢方坯6. bloom 钢坯,钢锭7. section 型材8. steel ingot 钢锭9. blank 坯料，半成品10. cast steel 铸钢11. nodular cast iron 球墨铸铁12. ductile cast iron 球墨铸铁13. bronze 青铜14. brass 黄铜15. copper 合金16. stainless steel不锈钢17. decarburization 脱碳18. scale 氧化皮19. anneal 退火20. process anneal 进行退火21. quenching 淬火22. normalizing 正火23. Charpy impact text 夏比冲击试验24. fatigue 疲劳25. tensile testing 拉伸试验26. solution 固溶处理27. aging 时效处理28. Vickers hardness维氏硬度29. Rockwell hardness 洛氏硬度30. Brinell hardness 布氏硬度31. hardness tester硬度计32. descale 除污，除氧化皮等33. ferrite 铁素体34. austenite 奥氏体35. martensite马氏体36. cementite 渗碳体37. iron carbide 渗碳体38. solid solution 固溶体39. sorbite 索氏体40. bainite 贝氏体41. pearlite 珠光体42. nodular fine pearlite/ troostite屈氏体43. black oxide coating 发黑44. grain 晶粒45. chromium 铬46. cadmium 镉47. tungsten 钨48. molybdenum 钼49. manganese 锰50. vanadium 钒51. molybdenum 钼52. silicon 硅53. sulfer/sulphur 硫54. phosphor/ phosphorus 磷55. nitrided 氮化的56. case hardening 表面硬化，表面淬硬57. air cooling 空冷58. furnace cooling 炉冷59. oil cooling 油冷60. electrocladding /plating 电镀61. brittleness 脆性62. strength 强度63. rigidity 刚性,刚度64. creep 蠕变65. deflection 挠度66. elongation 延伸率67. yield strength 屈服强度68. elastoplasticity 弹塑性69. metallographic structure 金相组织70. metallographic test 金相试验71. carbon content 含碳量72. induction hardening 感应淬火73. impedance matching 感应淬火74. hardening and tempering 调质75. crack 裂纹76. shrinkage 缩孔，疏松77. forging 锻（件）78. casting 铸（件）79. rolling 轧（件）80. drawing 拉（件）81. shot blasting 喷丸（处理）82. grit blasting 喷钢砂（处理）83. sand blasting 喷砂（处理）84. carburizing 渗碳85. nitriding 渗氮86. ageing/aging 时效87. grain size 晶粒度88. pore 气孔89. sonim 夹砂90. cinder inclusion 夹渣91. lattice晶格92. abrasion/abrasive/rub/wear/wearing resistance (property) 耐磨性93. spectrum analysis光谱分析94. heat/thermal treatment 热处理95. inclusion 夹杂物96. seGREgation 偏析97. picking 酸洗，酸浸98. residual stress 残余应力99. remaining stress 残余应力100. relaxation of residual stress 消除残余应力101. stress relief 应力释放A R steel 高温度锰钢abnormal steel 反常钢; 非正常钢aluminium-steel cable 钢铝电缆aluminized steel 涂铝钢aluminum nickel steel 铝镍钢anchored steel trestle 锚固式钢栈桥angle steel ruler 钢角尺anisotropic steel 各向异性钢片anisotropy silicon steel 各向异性硅钢片annealed sheet steel 退火薄钢板annealed steel 退火钢; 韧钢anti-creeping angle steel 防爬角铁anticorrosive aluminium-coated steel wire 防蚀镀铝钢丝arc-furnace steel 电炉钢arc-welded steel pipe 电弧焊接钢管area of steel 钢筋断面面积; 钢筋截面面积area of structural steel 型钢截面积Armco aluminized steel 阿姆柯渗铝钢armco aluminized steel 表面浸镀铝钢Armco stabilized steel 阿母柯稳定化钢Armco steel 阿姆柯软钢armco steel 不硬化钢austenilic Ni-Cr stainless steel 奥氏体镍铬不锈钢austenitic alloy steel 奥氏体合金钢austenitic chromium-nickel steel 奥氏体铬-镍钢austenitic clad steel 奥氏体复合钢austenitic heat-resistance steel 奥氏体耐热钢austenitic manganese steel 奥氏体锰钢; 哈德菲尔德锰钢austenitic stainless steel 奥氏体不锈钢austenitic steel 奥氏体钢automatic steel 易切削钢automatic(al) steel 易切削钢axle shaft steel 车轴钢axle steel 车轴钢钢铁业的英语词汇1Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Case-Hardened Steel 表面渗碳硬化钢; 渗碳钢Bolts & Nuts For Steel Slotted 角钢螺丝Cast Alloy Steel Piston 合金铸钢活塞Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 铸造不锈钢Cast Steel 铸钢件Cast Steel Plate 铸钢板Cast(Carbon) Steel 铸钢Cast-In Steel Bush 铸入钢套Casement Section Steel 窗框钢Cast-Steel 铸钢Cast-Steel Crossing 铸钢辙叉Cast-Steel Pipe 铸钢管Cast-Steel Separator 铸钢隔板; 铸钢横梁Cast-Steel Shot 钢砂Cast-Steel Yoke 铸钢轭Cellular Steel Floor 格型钢楼板Cement-And-Grouted Steel Bolt 钢筋砂浆锚杆Cemented Steel 表面硬化钢Cemented Templet Steel 渗碳样板钢Centra Steel 球状石墨铸钢Centrifugal Steel 离心铸钢Centrifuge(D) Steel 离心铸造钢Channel Steel 槽钢Channel-Section Steel 槽形钢Channeled-Steel Wheel Rim 槽钢制轮辋Checkered Steel Plate 花纹钢板Chemical Capped Steel 化学封顶钢Chilled Cast Steel 冷硬铸钢Chilled Hardened Steel 淬火钢Chilled Steel 淬火钢; 淬硬钢Chisel Steel 凿钢; 凿子钢Chrome Hardened Steel 铬硬化钢Chrome Steel 铬钢Chrome-Carbon Steel 铬碳钢Chrome-Manganese Nitrogen Steel 铬锰氮钢Chrome-Manganese-Silicon Alloy Steel 铬锰硅合金钢Chrome-Molybdenum Steel 铬钼钢Chrome-Nickel Steel 铬镍钢Chrome-Plated Steel Nozzle 镀铬钢喷管Chrome-Silicon Steel 铬硅钢Chrome-Tungsten Steel 铬钨钢Chrome-Vanadium Steel 铬钒钢Chromemanganese Steel 铬锰钢Chromium Nickel Steel 高强度耐蚀铬镍钢Chromium Stainless Steel 铬不锈钢Chromium Steel 铬钢Chromium-Molybdenum Steel 铬钼钢Chromium-Nickel Steel 铬镍钢Chromium-Plated Mild Steel Animal Chain 镀铬软钢动物链条Chromium-Tungstenvanadium Steel 铬钨钒钢Chromiummanganese Steel 铬锰钢Chromiumnickel Austenite Stainless Steel 铬镍奥氏体不锈钢Chromiumplated Thin-Walled Steel Cylinder Liner 钢质薄壁镀铬汽缸衬套Chromized Steel 渗铬钢Circular Steel Support 环形金属支架Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel 包覆钢Cladding Steel Sheet 复合钢板Clean Steel 纯净钢; 洁净钢Closed Die Steel 闭锻模钢Coarse-Grained Steel 粗晶粒钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧钢Cold-Rolled Carbon Spring Steel 冷轧弹簧碳钢Cold-Rolled Carbon Steel 冷轴碳钢Cold-Rolled Steel Strip 冷轧带钢Cold-Shaping Steel 冷变形钢Cold-Short Steel 冷脆钢Cold-Steel 利器Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Coldshort Steel 冷脆钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Column With Steel Hooping 螺旋箍筋柱Combined Steel And Concrete Column 钢骨混凝土柱Comminuted Steel Shot 钢粉Common Straight Carbon Steel 普通碳素钢Complex Alloy Steel 多元合金钢; 合金钢碳素结构钢Carbon Construction Steel碳素工具钢Carbon Tool Steel合金结构钢Alloy Construction Steel合金工具钢Alloy Tool Steel高速工具钢High Speed Tool Steel弹簧钢Spring Steel不锈耐热钢Stainless & Heat Resisting Steel轴承钢Bearing Steel工字钢Ibeam普通圆钢Round Steel槽钢Channel扁钢Flat Steel Bar等边角钢Equal Angle Steel不等边角钢Unequal Angle Steelh型钢Hbeam钢坯Billet,Bloom钢筋混凝土用变形钢筋High Strength Deformed Steel Bar 窗框钢Window Sash中厚钢板Steel Plate热轧钢板（卷）Hot Rolled Steel Coil冷轧钢板（卷）Cold Rolled Steel Sheel or Coil镀锌钢板（卷）Galvanized Steel Coil钢带Steel Strip线材Wire Rod Coil无缝钢管Seamless Steel Pipe锅炉管Boiler Tube石油套管Pipe For Oil Field高压管Pressure Pipe高压气瓶用管Tube for High-Pressure Vessel地质钻探用管Seamless Steel Pipe For Geological Drill In 镀锌焊管Galvanized Welded Pipe石油钻探杆Drill Pipe For Oil Field铸铁管Cast Iron Pipe重轨Heavy Rail轻轨Light Rail炼钢生铁Basic Pig Iron铸造生铁foundry Pig Iron普通圆钢钉Round Nails for General Uses镀锌底碳钢丝Galvanized Low Carbon Steel Wire.钢丝绳Steel Wire Rope钢绞线Stranded Wire预应力混凝土钢丝Steel Wire For Prestressed Concrete 窗纱Window Screen车轮Wheel Tyre轮筛Wheel Circleiron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模(美作:mold) tuyere, nozzle 风口ingot mould 锭模(美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬(美作:blowtorch) crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿(美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型(美作:molding) calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔钢铁业的英语词汇2Abnormal Steel 反常钢; 非正常钢Aluminum-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Anchored Steel Trestle 锚固式钢栈桥Angle Steel Ruler 钢角尺Anisotropic Steel 各向异性钢片Anisotropy Silicon Steel 各向异性硅钢片Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Anti-Creeping Angle Steel 防爬角铁Anticorrosive Aluminum-Coated Steel Wire 防蚀镀铝钢丝1. Arc-Furnace Steel 电炉钢Arc-Welded Steel Pipe 电弧焊接钢管Area Of Steel 钢筋断面面积; 钢筋截面面积Area Of Structural Steel 型钢截面积Armco Aluminized Steel 阿姆柯渗铝钢Armco Aluminized Steel 表面浸镀铝钢Armco Stabilized Steel 阿母柯稳定化钢Armco Steel 阿姆柯软钢Armco Steel 不硬化钢Austenitic Ni-Cr Stainless Steel 奥氏体镍铬不锈钢Austenitic Alloy Steel 奥氏体合金钢Austenitic Chromium-Nickel Steel 奥氏体铬-镍钢Austenitic Clad Steel 奥氏体复合钢Austenitic Heat-Resistance Steel 奥氏体耐热钢Austenitic Manganese Steel 奥氏体锰钢; 哈德菲尔德锰钢Austenitic Stainless Steel 奥氏体不锈钢Austenitic Steel 奥氏体钢Automatic Steel 易切削钢Automatic(Al) Steel 易切削钢Axle Shaft Steel 车轴钢Axle Steel 车轴钢Bain tic Steel 贝氏体钢Balanced Steel 半镇静钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Bamboo Steel 竹节钢筋Band Steel 带钢Banding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Basic Bessemer Steel 碱性贝氏转炉钢Basic Bessemer Steel 碱性转炉钢Basic Bessemer Steel Converter 碱性转炉钢转炉Basic Converter Steel 碱性转炉钢Basic Electric Furnace Steel 碱性电炉钢Basic Open Hearth Steel 碱性平炉钢Battened Steel Column 双肢钢Beam Steel Plate 大梁钢板Beam With Compression Steel 双筋梁Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Bent Steel 挠曲钢筋Bessemer Low Carbon Steel 酸性转炉低碳钢Bessemer Mild Steel 贝色麦钢Bessemer Steel 贝色麦钢; 酸性钢Best Plough Steel Wire 铅淬火高强度钢丝Billet Steel 坯段钢; 钢坯; 短条钢Binary Steel 二元合金钢Black Mild Steel Carriage Bolt And Nut 黑铁马车螺丝闩Black Mild Steel Fish Bolt And Nut 黑铁鱼尾螺丝闩Black Mild Steel Flat Head Rivet 黑铁扁头铆钉Black Mild Steel Flat Head Tin men Rivet 黑铁号头铆钉Black Mild Steel Hexagonal Nut 黑铁六角螺丝帽Black Mild Steel Pan Head Rivet 黑铁锥头铆钉Black Mild Steel Round Head Rivet 黑铁圆头铆钉Black Mild Steel Square Nut 黑铁四方螺丝帽Black Steel Pipe 黑钢板Black Steel Sheet 黑钢皮Black Tin Steel 黑钢板Blister Steel 泡钢; 泡面钢Abnormal Structure Steel 反常组织钢Abrasion-Resistant Steel 耐磨钢Blue Steel 蓝钢Bluing Of Steel 钢加蓝Boiler Steel 锅炉钢; 锅炉钢板Boiler Steel Plate 锅炉钢板Boiling Steel 沸腾钢Bolting Steel 螺栓钢Blue Planished Steel 发蓝薄钢板Bloom Steel 初轧钢; 钢坯Boron Steel 硼钢Brass Fitting Of Steel Window 钢窗铜配件Brass-Plated Mild Steel Round Bead Wood Screw 镀黄铜圆头软钢木螺丝Brass-Plated Mild Steel Round Head Machine Screw 镀黄铜圆头软钢机器螺丝Brass-Plated Steel Wire 镀黄铜钢丝Brearley Steel 布里阿雷不锈钢; 布氏高铬钢Bridge Steel 桥梁钢Bright And Black Mild Steel Flat Head Tinmen Rivet 号头铆钉Bright Mild Steel Cotter Pin 光亮软钢开尾销Bright Mild Steel Countersunk Head Wood Screw 光亮软钢平头木螺丝Bright Mild Steel Hexagonal Nut 光亮软钢六角螺丝帽Bright Mild Steel Hexagonal Nuts 六角光螺帽; 六角螺丝帽Bright Mild Steel Hexagonal Pressed Nut 光亮软钢六角冲压螺丝帽Bright Mild Steel Round Head Wood Screw 光亮软钢圆头木螺丝Bright-Drawn Free Cutting Steel 光拉自由切削钢Bright-Drawn Steel 光亮拉拔钢材Bright-Finished Steel 光亮精整钢Bristol Steel Belt Lacing 布瑞斯涛钢带接头Bronze Steel 镀青铜钢Building Of Steel Frame Construction 钢框架房屋Bulb Steel 球扁钢Bulb-Rail Steel 球头丁字钢Burned Steel 过烧钢Calorized Steel 涂铝钢; 渗化钢Calorizing Steel 铝化钢Capped Steel 加盖钢; 半镇静钢Carbon And Low-Alloy Steel Vessels 碳钢及低合金钢容器Carbon Content Of Steel 钢含碳量Carbon Molybdenum Steel 钼碳钢Carbon Steel 碳钢; 碳素钢Carbon Steel Covered Electrode 碳钢焊条Carbon Steel Plate2. 中文名英文名品质描述6063 6063 Extrusion-pntd 镀漆6061 6061 Extrusion-pntd 镀漆生铝件Tense 含铁〈2% 生杂铝Mixed Cast 含铁〈2% 旧铝片Old Sheet-Taint/Tabor 干净新铝片Tough-Taboo 干净切碎铝Shredded Aluminum 干净汽车切片铝Shredded Auto Aluminum 含铝70% 带铁铝Irony Aluminum 需标明含量356轮毂铝356 Auto Wheels 干净铝水箱Aluminum Radiator 干净带皮铝线Acsr/Ins 需标明含量铜铝水箱Al/Cu Radiator 干净易拉罐UBC-Baled/Densified 干净铝变压器Aluminum Transformer铝壳马达Aluminum Case Motor1#光亮铜线#1 Bare Bright 干净1#铜#1 Candy 含铜98% 2#铜#2 Birch/Cliff 含铜94-96% 1#火烧线#1 Burnt Wire 含铜〉97% 1#铜米#1 Cu-chop1#铜线缆#1 Insulated Wire 含铜72%2#铜线缆#2 Insulated Wire 含铜50-55% 1#2#混合铜线缆#1#2 Mixed Wire 含铜65% 黄杂铜Yellow Brass-Honey 干净干净铜水箱Ocean Auto Radiator 干净(牛粪)切碎电机Shredded Pickings 含铜18-20% 混合电机Electric Motors 含铜8-12% 304炉料304 Sabot 18-8304可利用料304 Reusable 板或杆316可利用料316 Reusable 板或杆3. 1、烧结sintering粉末或压坯在低于主要组分熔点的温度下的热处理，目的在于通过颗粒间的冶金结合以提高其强度。